SO3采样技术改进及烟气处理设备SO3脱除能力测试

doi:10.11930/j.issn.1004-9649.201706037

摘要/Abstract

摘要： 燃煤烟气中SO₃由于其特有的化学性质，一直是国内外燃煤电厂污染物测试的难点之一。参照国内应用广泛的SO₃控制冷凝法，自制了一套SO₃采样系统，在综合考虑烟气SO₃采样过程中的各种影响因素后，通过试验模拟，确定了SO₃控制冷凝法采样系统最佳蛇形管内径、圈径和圈数，以及采样管、过滤器和循环水浴的伴热温度控制，从而提高了SO₃的捕集效率。利用该SO₃采样系统对烟气进行采样，测试燃煤锅炉烟气处理设备对SO₃的脱除能力，分析其影响因素及捕集机理。结果显示：SCR脱硝催化剂对SO₂具有一定的催化作用，且随烟气温度的升高，SO₂/SO₃转化率升高；对于SO₃的脱除效率（各设备进出口浓度对比），干式除尘设备可达80%以上，湿法脱硫设备为35%~40%；湿式电除尘器为70%~75%。

关键词: 燃煤电厂, 烟气采样, SO₃, 控制冷凝法, SO₂/SO₃转化率, 烟气处理设备, SO₃脱除能力

Abstract: Due to its unique chemical properties, SO₃ in coal-fired flue gas has been one of the difficult parts in pollutant testing in coal-fired power plants both at home and abroad. In this article, the SO₃ testing system is developed by utilizing the widely used control-condensation method and taking various factors into consideration during the sampling process. The optimal inner diameter, ring diameter and the number of rings of snake-shaped tube in SO₃ controlled condensation sampling system are determined through experimental simulation as well as the sampling tubes, the temperature control of filter and circulating water bath to improve the capture efficiency of SO₃. This SO₃ sampling system has been used to test the removal capability of the flue gas treatment equipment in the coal-fired boiler. The influencing factors and the trapping mechanism on SO₃ by sampling the flue gas are also analyzed. It is showed that SCR catalyst had some catalytic effects on SO₂, and the conversion rate of SO₂/SO₃ increases with higher flue gas temperature. As for the removal efficiency of SO₃, based on the comparison results of the inlet and outlet concentration between each equipment, the dry dedusting equipment can reach more than 80%, while the wet desulphurization equipment is 35%~40% and the wet electrostatic precipitator is 70%~75%.

Key words: coal-fired power plants, flue gas sampling, SO₃, controlled condensation method, SO₂/SO₃ percent conversion, flue gas treatment equipment, SO₃ removal ability

中图分类号:

X701.3

杨丁, 陈永强, 陈威祥, 郑芳, 林启超. SO₃采样技术改进及烟气处理设备SO₃脱除能力测试[J]. 中国电力, 2018, 51(7): 157-161.

YANG Ding, CHEN Yongqiang, CHEN Weixiang, ZHENG Fang, LIN Qichao. Improvement of SO₃ Sampling Technology and SO₃ Removal Capability Testing of Flue Gas Treatment Equipment[J]. Electric Power, 2018, 51(7): 157-161.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.201706037

https://www.electricpower.com.cn/CN/Y2018/V51/I7/157

参考文献

[1] 王宏亮, 薛建明, 许月阳, 等. 燃煤电站锅炉烟气中SO₃的生成及控制[J]. 电力科技与环保, 2014, 30(5):17-20.WANG Hongliang, XUE Jianming, XU Yueyang, et al. Formation and control of SO₃ from coal - fired power plants[J]. Electric Power Technology and Environmental Protection, 2014, 30(5):17-20.
[2] 李彦, 武彬, 徐旭常. SO₂、SO₃和H₂O对烟气露点温度影响的研究[J]. 环境科学学报, 1997, 17(1):126-130.LI Yan, WU Bin, XU Xuchang, Study on the influence of SO₂、SO₃ and H₂O on the temperature of flue gas[J]. Journal of Environmental Science, 1997, 17(1):126-130.
[3] 崔娟玲, 郭昭胜. 150 m高钢筋混凝土烟囱及烟道腐蚀检测及分析[J]. 中国电力, 2015, 48(5):7-11.CUI Juanling, GUO Zhaosheng. Inspection and analysis of the corrosion of 150-meter super high reinforced concrete chimney and flue[J]. Electric Power, 2015, 48(5):7-11.
[4] SRIVASTAVA R K, MILLER C A, ERICKSON C, et al. Emissions of sulfur trioxide from coal-fired power plants[J]. Journal of the Air & Waste Management Association, 2004, 54(6):750-762.
[5] 肖雨亭, 贾曼, 徐莉, 等. 烟气中三氧化硫及硫酸雾滴分析方法[J]. 环境科技, 2012, 25(5):43-48.XIAO Yuting, JIA Man, XU Li, et al. The analytic method of sulfur trioxide and sulfuric acid mist in flue gas environmental science and technology[J]. Environmental Science and Technology, 2012, 25(5):43-48.
[6] RONL O, MATTHEW S D. Controlled condensation method for flue gas SO₃ measurement[EB/OL]. (2011-12-16)[2017-01-08]. http://www.metl.doe.gov/publications/proceedings/98/98fg/oda.pdf.
[7] NIELSEN M T. On the relative importance of SO₂ oxidation to high dust SCR DeNO_x units[C]//DOE/NETL Conference on Selective Catalytic Reduction (SCR) and Selective Non-Catalytic Reduction (SNCR) for NO_x Control. Lyngby, 2003.
[8] 魏宏鸽, 程雪山, 马彦斌, 等.燃煤烟气中SO₃的产生与转化及其抑制对策探讨[J]. 发电与空调, 2012, 33(2):1-4.WEI Hongge, CHENG Xueshan, MA Yanbin, et al. Some discussion about SO₃'s generation, transformation and its inhibiting methods in coal-fired flue gas[J]. Refrigeration Air Conditioning & Electric Power Machinery, 2012, 33(2):1-4.
[9] 张建中. 火电厂烟气脱硫脱硝项目中有关烟气特性计算方法若干问题的讨论[J]. 电力环境保护, 2008, 24(4):6-10.ZHANG Jianzhong.Discussion on problems of flue gas properties calculation methods in thermal power plants desulfurization and denitrification projects[J]. Electric Power Environmental Protection, 2008, 24(4):6-10.
[10] 张悠. 烟气中SO₃测试技术及其应用研究[D]. 杭州:浙江大学, 2013.
[11] 吴宁, 宋蔷, 李水清, 等SCR烟气脱硝过程中SO₂和SO₃的测量[J]. 煤炭转化, 2006, 29(2):84-87.WU Ning, SONG Qiang, LI Shuiqing, et al. Measurement of SO₂ and SO₃ in SCR flue gas denitrification[J]. Coal Conversion, 2006, 29(2):84-87.
[12] 朱崇兵, 金保升, 李峰, 等. SO₂氧化对SCR法烟气脱硝的影响[J]. 锅炉技术, 2008, 39(3):68-70.Zhu Chongbing, Jin Baosheng, Li Feng, et al. Effect of SO₂ oxidation on denitration of SCR flue gas[J]. Boiler Technology, 2008, 39(3):68-70.
[13] 马双忱, 金鑫, 孙云雪, 等.SCR烟气脱硝过程硫酸氢铵的生成机理与控制[J]. 热力发电, 2010, 39(8):12-17.MA shuangchen, JIN Xin, SUN yunxue, et al. The formation mechanism of ammonium bisulfate in SCR flue gas denitrification process and control thereof[J]. Thermal Power Generation, 2010, 39(8):12-17.
[14] 胡斌, 刘勇, 任飞, 等.低低温电除尘协同脱除细颗粒与SO₃实验研究[J]. 中国电机工程学报, 2016, 36(16):4319-4325.HU Bin, LIU Yong, REN Fei, et al. Experimental study on simultaneous control of fine particle and SO₃ by low-low temperature electrostatic precipitator[J]. Proceedings of the CSEE, 2016, 36(16):4319-4325.
[15] FU Wenling, ZHOU Hao, MORETTI A L, 等.有效的SO₃脱除技术-烟道喷吸收剂和安装湿式电除尘器[C]//第十六届二氧化硫、氮氧化物、汞、细颗粒物污染控制技术研讨会. 厦门, 2012.
[16] 张建中.燃煤烟气降温除尘过程中SO₃浓度的浓淡分离现象及对酸露点温度影响的分析[J]锅炉技术, 2015, 46(3):12-18.ZHANG Jianzhong.Dense-dilute separation phenomenon of SO₃ concentration during the coal-fired flue gas cooling and dedusting process and analysis on the influence of acid dew point temperature[J]. Boiler Technology, 2015, 46(3):12-18.
[17] ROBERT E. SO₃'s impacts on plant O&M:Part Ⅰ[EB/OL]. (2006-10-15)[2017-01-08]. http://www.powermag.com/SO3s-impacts-on-plant-om-part-i/.
[18] 潘丹萍, 吴昊, 黄荣延, 等.石灰石-石膏法烟气脱硫过程中SO₃酸雾脱除特性[J]. 东南大学学报(自然科学版), 2016, 46(2):311-316.PAN Danping, WU Hao, HUANG Rongting et al. Removal properties of sulfuric acid mist during limestone-gypsum flue gas desulfurization process[J]. Journal of Southeast University(Natural Science Edition), 2016, 46(2):311-316.
[19] ROBERT E, SO₃'s impacts on plant O&M:Part Ⅱ[EB/OL]. http://www.powermag.com/SO3s-impacts-on-plant-om-part-ii/, 2007-02-01.
[20] 闫军. 湿式静电除雾器脱除烟气中酸雾的试验研究[D]. 济南:山东大学, 2010.
[21] 陈招妹, 王剑波, 姚宇平, 等. 湿式电除尘器在燃煤电厂WFGD后的应用分析[C]//第十五届中国电除尘学术会议论文集. 蚌埠, 2013.

SO₃采样技术改进及烟气处理设备SO₃脱除能力测试

Improvement of SO₃ Sampling Technology and SO₃ Removal Capability Testing of Flue Gas Treatment Equipment

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	刘东旭, 张潇元, 马青, 冯前伟, 杜振. 燃煤机组SO₃生成与控制技术路线分析[J]. 中国电力, 2024, 57(6): 235-242.
[2]	刘毅. 燃煤电厂烟气中SO₃排放控制中试研究[J]. 中国电力, 2022, 55(7): 201-208.
[3]	刘含笑, 吴黎明, 赵琳, 于立元, 郦建国, 崔盈. 燃煤电厂湿式电除尘器减排及能效特性研究[J]. 中国电力, 2022, 55(5): 196-203.
[4]	孙尊强, 郑成航, 周灿, 王圣, 马修元, 叶毅科. 燃煤电厂典型除尘器运行现状分析及优化[J]. 中国电力, 2022, 55(11): 194-201.
[5]	吴家玉, 莫华, 胡耘, 朱杰, 帅伟, 张晴, 姜岸. 京津冀及周边地区燃煤电厂煤场无组织颗粒物不同控制情景下时空变化特征[J]. 中国电力, 2021, 54(2): 182-189.
[6]	赵宏, 张发捷, 马云龙, 马宝林, 唐潇, 徐仁博, 罗通达, 李成宝, 任传明, 于洁, 孙路石. 燃煤电厂SCR脱硝氨逃逸迁移规律试验研究[J]. 中国电力, 2021, 54(1): 196-202.
[7]	张志强, 朱法华, 邹斯诣, 史鹏飞, 王晓玲, 游秦, 姚力, 闫绍帅, 王兴. 基于实测的烟气“消白”工程环境效益研究[J]. 中国电力, 2020, 53(9): 202-207.
[8]	赵柄, 王海刚, 胡冬, 陈坤洋, 金绪良, 殷爱鸣. 燃煤电厂碱性吸附剂脱汞性能研究[J]. 中国电力, 2020, 53(9): 208-213.
[9]	吴家玉, 朱杰, 莫华, 张峰, 帅伟, 张晴, 那钦. 典型燃煤电厂浆液冷却烟气消白设施SO₃治理效果测试研究[J]. 中国电力, 2020, 53(8): 145-150,172.
[10]	姚燕, 马云龙, 杨晓宁, 张华东, 王丽朋. 高砷煤SCR脱硝催化剂中毒失活研究[J]. 中国电力, 2020, 53(6): 191-196.
[11]	马学礼, 孙希进, 苏燊燊, 张仁锋, 党立晨, 黄显昌, 谢永平. 基于超低排放的燃煤电厂烟囱高度优化研究[J]. 中国电力, 2020, 53(5): 179-184.
[12]	徐静馨, 朱法华, 王圣, 张明, 赵秀勇, 孙雪丽, 胡耘, 田文鑫. 超低排放燃煤电厂和燃气电厂综合对比[J]. 中国电力, 2020, 53(2): 164-172,179.
[13]	李滨, 杨阳. 烟气SO₃监测控制冷凝法采样方法[J]. 中国电力, 2020, 53(1): 140-146.
[14]	王文欣, 高毅, 刘春红, 童小忠, 陈彪, 祁志福, 张勤. 燃煤电厂旁路烟气干燥塔控制技术开发[J]. 中国电力, 2020, 53(1): 147-154.
[15]	雷嗣远, 李海浩, 李乐田, 倪贵东, 孔凡海, 吴国勋, 卞子君. SCR脱硝低负荷投运烟气调温旁路改造设计[J]. 中国电力, 2019, 52(9): 179-184.

模态框（Modal）标题