二次再热机组高效灵活发电创新理论与方法

doi:10.11930/j.issn.1004-9649.201903075

中国电力 ›› 2019, Vol. 52 ›› Issue (5): 1-12.DOI: 10.11930/j.issn.1004-9649.201903075

• 智能发电关键技术专栏 • 上一篇下一篇

二次再热机组高效灵活发电创新理论与方法

段立强¹, 王婧¹, 庞力平¹, 种道彤², 俞基安³, 刁保圣⁴, 吕春俊⁴

1. 华北电力大学能源动力与机械工程学院, 北京 102206;
2. 西安交通大学能源与动力工程学院, 陕西西安 710049;
3. 国家能源集团江苏电力有限公司, 江苏南京 210036;
4. 国家能源集团宿迁发电有限公司, 江苏宿迁 223800

收稿日期:2019-03-23 修回日期:2019-04-23 出版日期:2019-05-05 发布日期:2019-05-14
作者简介:段立强(1973-),男,通信作者,教授,从事先进能量系统集成与优化研究,E-mail:dlq@ncepu.edu.cn;王婧(1984-)女,博士研究生,高级工程师,从事超超临界机组系统优化研究,E-mail:185831042@qq.com;庞力平(1968-),男,博士,教授,从事气液两相流管内流动和电站锅炉性能监测研究,E-mail:plp@ncepu.edu.cn;liping_pang@163.com;种道彤(1978-),男,博士,教授,从事热力系统节能及其过程控制研究,E-mail:dtchong@mail.xjtu.edu.cn;俞基安(1964-),男,硕士,高级工程师,从事火电厂建设、生产及运营管理研究,E-mail:12069143@chnenergy.com.cn
基金资助:
国家重点研发计划资助项目（2017YFB0602101）。

Innovative Theory and Methods for High-Efficiency and Flexible Power Generation of Ultra-supercritical Double-Reheat Coal-Fired Power Generation Unit

DUAN Liqiang¹, WANG Jing¹, PANG Liping¹, CHONG Daotong², YU Ji'an³, DIAO Baosheng⁴, LV Chunjun⁴

1. School of Energy Power and Mechanical Engineering, North China Electric Power University, Beijing 102206, China;
2. School of Energy and Power Engineering, Xi'an Jiaotong University, Xi'an 710049, China;
3. National Energy Group Jiangsu Electric Power Co., Ltd., Nanjing 210036, China;
4. National Energy Group Suqian Power Generation Co., Ltd., Suqian 223800, China

Received:2019-03-23 Revised:2019-04-23 Online:2019-05-05 Published:2019-05-14
Supported by:
This work is supported by National Key Research and Development Program of China (No.2017YFB0602101).

摘要/Abstract

摘要： 为解决二次再热机组在频繁变负荷情况下经济性能偏低、灵活性较差等问题，研究了二次再热高效灵活发电创新理论和方法。基于单耗分析方法揭示了传统二次再热机组全工况能耗分布规律，并提出5种适应电网调峰要求的典型600 ℃等级及以上的先进二次再热超超临界燃煤发电系统，分别为集成回热式小汽机新型循环、机炉深度耦合集成新循环、采用新型CO₂工质的循环、带储能的二次再热循环系统以及太阳能热互补二次再热循环系统，阐述了各循环系统的集成思路、系统特点以及对提高机组经济性和灵活性的优势。结果表明：锅炉、汽轮机、回热加热器具有较大的节能潜力；优选的集成回热式汽轮机的二次再热循环系统发电效率比基准系统煤耗降低了2.15 g/（kW·h）；提出的采用机炉耦合技术的二次再热机组在THA工况下煤耗降低高达3.6 g/（kW·h）；采用CO₂工质的火电系统在变工况下依然具有较高的效率；带储能的二次再热循环系统具有较好的灵活性；太阳能热互补二次再热循环系统节能潜力显著，达到14.73 g/（kW·h）。

关键词: 智能发电, 集成系统, 灵活, 二次再热, CO₂工质循环

Abstract: Regarding the problems such as low economic performance and lack of flexibilities during the operations of double-reheat ultra-supercritical coal-fired power generation unit under frequent load change conditions, this paper studies the innovative theory and methods for high-efficiency and flexible power generation of ultra-supercritical double-reheat coal-fired power generation unit. Firstly, on the base of the specific fuel consumption method, the energy consumption distribution regularities of a traditional double-reheat coal-fired power generation unit under different load conditions are revealed. Then five types of new advanced double-reheat coal-fired power generation systems are proposed in this paper, which are all designed with the main steam temperatures of over 600℃ and more advanced capabilities of accommodating the peak load regulations, i.e., double-reheat power generation cycle integrated with the regenerative small steam turbine, double-reheat power generation cycle with the deep coupling between the boiler and turbine system, new double-reheat power generation cycle with CO₂ as the working medium, double-reheat power generation cycle with energy storage system and double-reheat power generation cycle integrated with the solar energy, respectively. Their ideas of integration and characteristics of these new cycle systems in improving the economic performance and operation flexibility are elaborated in details. The research results are illustrated as follows:boilers, steam turbines and regenerative heaters have great energy-saving potential; the standard coal consumption rate of the optimized double-reheat power generation cycle with the regenerative small steam turbine is 2.15 g/(kW·h) lower than that of the reference system; the coal consumption of double-reheat power generation cycle with the deep coupling between the boiler and turbine system can be reduced by 3.6 g/(kW·h) under THA condition; the coal-fired power plant with CO₂ as the working medium still has high efficiency even under load variation conditions; the double-reheat power generation cycle with energy storage system has better flexibility, while the double-reheat power generation cycle integrated with the solar energy has significant energy-saving potential, which can reduce coal consumption by as much as 14.73 g/(kW·h).

Key words: intelligent generation, integrated system, flexibility, double-reheat, CO₂ working medium cycle

中图分类号:

TK11+4

段立强, 王婧, 庞力平, 种道彤, 俞基安, 刁保圣, 吕春俊. 二次再热机组高效灵活发电创新理论与方法[J]. 中国电力, 2019, 52(5): 1-12.

DUAN Liqiang, WANG Jing, PANG Liping, CHONG Daotong, YU Ji'an, DIAO Baosheng, LV Chunjun. Innovative Theory and Methods for High-Efficiency and Flexible Power Generation of Ultra-supercritical Double-Reheat Coal-Fired Power Generation Unit[J]. Electric Power, 2019, 52(5): 1-12.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.201903075

https://www.electricpower.com.cn/CN/Y2019/V52/I5/1

参考文献 20

[1]	李华杰, 马丽梅. 近年来我国能源投资发展分析[J]. 中外能源, 2018, 23(1):3-13 LI Huajie, MA Limei. Analysis on recent development of energy investment in China[J]. Sino-Global Energy, 2018, 23(1):3-13
[2]	YANG Yongping, GUO Xiyan, WANG Ningling. Power generation from pulverized coal in China[J]. Energy, 2010, 35(11):4336-4348.
[3]	乔加飞, 王斌, 陈寅彪, 等. 630℃高效超超临界二次再热机组关键技术研究[J]. 煤炭工程, 2017, 49(5):109-113 QIAO Jiafei, WANG Bin, CHEN Yinbiao, et al. Study on the key technology of 630℃ ultra-supercritical double reheat unit[J]. Coal Engineering, 2017, 49(5):109-113
[4]	高昊天, 范浩杰, 董建聪, 等. 超超临界二次再热机组的发展[J]. 锅炉技术, 2014, 45(4):1-3, 33 GAO Haotian, FAN Haojie, DONG Jiancong, et al. Development of ultra supercritical unit with double reheat cycle[J]. Boiler Technology, 2014, 45(4):1-3, 33
[5]	杨勤, 张世山, 杨宏强, 等. 泰州二期1000 MW超超临界二次再热机组建设与运行[J]. 中国电力, 2017, 50(6):38-42 YANG Qin, ZHANG Shishan, YANG Hongqiang, et al. Construction and operation of the 1000 MW ultra-supercritical double reheat unit in Taizhou Ⅱ[J]. Electric Power, 2017, 50(6):38-42
[6]	阳光, 陈仁杰, 朱佳琪. 1000 MW超超临界二次再热燃煤发电示范工程总体设计方案[J]. 中国电力, 2017, 50(6):12-16 YANG Guang, CHEN Renjie, ZHU Jiaqi. General design of 1000 MW ultra-supercritical double-reheat demonstration power plant[J]. Electric Power, 2017, 50(6):12-16
[7]	李永生, 徐星, 孙俊威. 超超临界二次再热机组性能试验及分析[J]. 电力科技与环保, 2017, 33(6):40-43 LI Yongsheng, XU Xing, SUN Junwei. The performance test and analysis of ultra supercritical double reheat units[J]. Electric Power Technology and Environmental Protection, 2017, 33(6):40-43
[8]	周云龙, 杨美, 王迪. 1000MW高超超临界二次再热系统优化[J]. 中国电机工程学报, 2018, 38(S1):137-141 ZHOU Yunlong, YANG Mei, WANG Di. Optimization of 1000MW high ultra-supercritical double-reheat system[J]. Proceedings of the CSEE, 2018, 38(S1):137-141
[9]	裴哲义, 王新雷, 董存, 等. 东北供热机组对新能源消纳的影响分析及热电解耦措施[J]. 电网技术, 2017, 41(6):1786-1792 PEI Zheyi, WANG Xinlei, DONG Cun, et al. Analysis of impact of CHP plant on renewable energy accommodation in northeast China and thermoelectric decoupling measures[J]. Power System Technology, 2017, 41(6):1786-1792
[10]	白永军. 100MW机组低真空深度调峰试验研究[D]. 北京:华北电力大学, 2004.
[11]	胡雍胜. 锅炉灵活性改造中省煤器烟气出口温度提升方案论证[M]. 中国工程热物理学会论文集, 2017.
[12]	刁美玲, 唐春丽, 朱信, 等. 超超临界二次再热机组热经济性及技术经济性分析[J]. 热力发电, 2017, 46(8):23-29 DIAO Meiling, TANG Chunli, ZHU Xin, et al. Thermoeconomic and techno-economic analysis on an ultra-supercritical unit with double-reheat cycle[J]. Thermal Power Generation, 2017, 46(8):23-29
[13]	HU E, YANG Y P, NISHIMURA A, et al. Solar thermal aided power generation[J]. Applied Energy, 2010, 87(9):2881-2885.
[14]	宋之平. 单耗分析的理论和实施[J]. 中国电机工程学报, 1992, 12(4):15-21 SONG Zhiping. Consumption rate analysis:Theory and practice[J]. Proceedings of the CSEE, 1992, 12(4):15-21
[15]	郑莆燕, 郭林彬, 王乔良, 等. 二次再热超超临界机组回热和再热参数的同步优化[J]. 汽轮机技术, 2018, 60(2):99-101 ZHENG Huiyan, GUO Linbin, WANG Qiaoliang, et al. Synchronous optimization of regenerative and reheating parameters for double reheat ultra-supercritical unit[J]. Turbine Technology, 2018, 60(2):99-101
[16]	ZHAO Yawen, HONG Hui, JIN Hongguang, et al. Thermodynamic mechanism for hybridization of moderate-temperature solar heat with conventional fossil-fired power plant[J]. Energy, 2017, 133:832-842.
[17]	张一帆, 王生鹏, 刘文娟, 等. 超临界二氧化碳再压缩再热火力发电系统关键参数的研究[J]. 动力工程学报, 2016, 36(10):827-833 ZHANG Yifan, WANG Shengpeng, LIU Wenjuan, et al. Study on key parameters of a supercritical fossil-fired power system with CO2 recompression and reheat cycles[J]. Journal of Chinese Society of Power Engineering, 2016, 36(10):827-833
[18]	IVERSON B D, CONBOY T M, PASCH J J, et al. Supercritical CO2 Brayton cycles for solar-thermal energy[J]. Applied Energy, 2013, 111:957-970.
[19]	王海军, 赵雅静, 杨玉江, 等. 熔盐储能技术的研究及熔盐供暖技术的应用前景[J]. 广州化工, 2017, 45(15):33-34, 47 WANG Haijun, ZHAO Yajing, YANG Yujiang, et al. Study on molten salt storage systems and application prospect of heating system using molten salt storage system[J]. Guangzhou Chemical Industry, 2017, 45(15):33-34, 47
[20]	毛剑, 杨勇平, 侯宏娟, 等. 太阳能辅助燃煤发电技术经济分析[J]. 中国电机工程学报, 2015, 35(6):1406-1412 MAO Jian, YANG Yongping, HOU Hongjuan, et al. Techno-economic analysis of solar thermal aided coal-fired power plants[J]. Proceeding of the CSEE, 2015, 35(6):1406-1412

二次再热机组高效灵活发电创新理论与方法

Innovative Theory and Methods for High-Efficiency and Flexible Power Generation of Ultra-supercritical Double-Reheat Coal-Fired Power Generation Unit

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics

[1]	章枫, 樊恒建, 邓晖, 房乐, 周子青, 李知艺. 基于数学形态学的电力系统灵活调节能力充裕度分析[J]. 中国电力, 2025, 58(3): 43-54.
[2]	张玉敏, 尹延宾, 吉兴全, 叶平峰, 孙东磊, 宋爱全. 计及热网不同运行状态下灵活性供给能力的综合能源系统优化调度[J]. 中国电力, 2025, 58(2): 88-102.
[3]	孙东磊, 王宪, 孙毅, 孟祥飞, 张涌琛, 张玉敏. 基于多面体不确定集合的电力系统灵活性量化评估方法[J]. 中国电力, 2024, 57(9): 146-155.
[4]	刘志强, 李建锋, 潘荔, 王志轩. 中国煤电机组改造升级效果分析与展望[J]. 中国电力, 2024, 57(7): 1-11.
[5]	徐峰亮, 王克谦, 王文豪, 王鹏, 王焕昌, 张帅, 赵凤展. 计及运行灵活性的中压配电系统源-网-储协同扩展规划[J]. 中国电力, 2024, 57(7): 98-108.
[6]	陈兴龙, 曹喜民, 陈洁, 刘俊, 张育超, 包洪印. 绿证-碳交易机制下热电灵活响应的园区综合能源系统优化调度[J]. 中国电力, 2024, 57(6): 110-120.
[7]	胡福年, 张彭成, 周小博, 陈军. 计及灵活性资源的综合能源系统源荷协调优化调度[J]. 中国电力, 2024, 57(5): 2-13.
[8]	张彩玲, 王爽, 葛淑娜, 潘登, 张岩, 韩伟, 段文岩. 计及灵活需求响应和碳-绿证交易的综合能源系统优化调度[J]. 中国电力, 2024, 57(5): 14-25.
[9]	李咸善, 丁胜彪, 李飞, 李欣. 考虑水电调节费用补偿的风光水联盟优化调度策略[J]. 中国电力, 2024, 57(5): 26-38.
[10]	张永, 尹朝强, 刘宇钢, 张斌, 莫春鸿, 王朝阳. 风煤比对超超临界机组变负荷瞬态特性的影响[J]. 中国电力, 2024, 57(3): 224-232.
[11]	仪忠凯, 侯朗博, 徐英, 吴永峰, 李志民, 吴俊飞, 冯腾, 韩柳. 市场环境下灵活性资源虚拟电厂聚合调控关键技术综述[J]. 中国电力, 2024, 57(12): 82-96.
[12]	许竞, 赵铁军, 高小刚, 叶鞠, 孙玲玲. 高比例新能源电力系统调节资源灵活性不足风险分析[J]. 中国电力, 2024, 57(11): 129-138.
[13]	刘志文, 李岩, 邵冲, 范心明, 曾庆辉. 考虑柔性资源协同互动的配电网灵活性评估方法[J]. 中国电力, 2024, 57(10): 158-165.
[14]	宋天琦, 吕志鹏, 宋振浩, 马韵婷, 张智慧, 周珊, 李昊. 虚拟电厂规模化灵活资源聚合调控框架研究与思考[J]. 中国电力, 2024, 57(1): 2-8.
[15]	朱睿, 欧乙丁, 李筱天, 雷星雨, 周宇晴, 张珀扬, 欧睿. 基于外特性等值的虚拟电厂灵活性资源价值评估[J]. 中国电力, 2024, 57(1): 30-39.

模态框（Modal）标题

二次再热机组高效灵活发电创新理论与方法

Innovative Theory and Methods for High-Efficiency and Flexible Power Generation of Ultra-supercritical Double-Reheat Coal-Fired Power Generation Unit

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 15

编辑推荐

Metrics