环境风对直接空冷凝汽器性能的影响及主导因素分析

doi:10.11930/j.issn.1004-9649.2013.11.113.5

中国电力 ›› 2013, Vol. 46 ›› Issue (11): 113-118.DOI: 10.11930/j.issn.1004-9649.2013.11.113.5

环境风对直接空冷凝汽器性能的影响及主导因素分析

高沛, 张学镭

华北电力大学电站设备状态监测与控制教育部重点实验室,河北保定 071003

收稿日期:2013-07-24 出版日期:2013-11-23 发布日期:2015-12-10
作者简介:高沛（1988—）,男,河北保定人,硕士研究生,从事电站冷端系统优化运行关键技术、先进能源动力系统的建模与优化等方面的研究。

Performance of Direct Air-Cooled Condenser Under Windy Conditions and Its Influencing Factors

GAO Pei, ZHANG Xue-lei

Key Laboratory of Ministry of Education of Condition Monitoring and Control for Power Plant Equipment,North China Electric Power University, Baoding 071003, China

Received:2013-07-24 Online:2013-11-23 Published:2015-12-10

摘要/Abstract

摘要： 环境风对直接空冷凝汽器的换热性能具有重要影响。以某300MW直接空冷机组为例,分步建立了空冷岛和每个空冷单元的数值分析模型。分析了环境风对直接空冷凝汽器换热性能的影响,得到了环境风工况下影响空冷凝汽器换热性能的主导因素。结果表明：位于空冷平台边缘的空冷单元,由于受到热风回流和倒灌的影响,其入口风温受环境风的影响较大;位于空冷平台迎风侧的空冷单元,因为负压区的存在降低了风机的性能,使其进气量受环境风的影响较大;空冷单元因风机性能下降所导致的进气量减少是造成空冷凝汽器性能降低的主导因素。

关键词: 直接空冷凝汽器, 空冷单元, 数值模拟, 主导因素

Abstract: The environmental wind has significant effects on the heat transfer efficiency of direct air-cooled condensers. By way of the example of a 300-MW direct air-cooled condenser, the models of the air-cooled island and the heat exchanger units are built for numerical analysis. The effects of the environmental wind on the heat transfer efficiency of the air-cooled condenser are studied, and the dominant factor contributing to the reduction of the efficiency under windy conditions is found out. The result shows that the air inlet temperature at the edge of the heat exchanger units is greatly influenced by the environmental wind due to the hot air recirculation and the backward flow; the air inflow of the heat exchanger units on the upwind side is also seriously affected by the environmental wind since there is a negative pressure zone existing that lowers the performance of the fan. The decrease of the air inflow due to the fan performance degradation is the major factor affecting the performance of the air-cooled condenser.

Key words: direct air-cooled condenser, air-cooled unit, numerical simulation, dominant factor

中图分类号:

TK264.1⁺1

高沛, 张学镭. 环境风对直接空冷凝汽器性能的影响及主导因素分析[J]. 中国电力, 2013, 46(11): 113-118.

GAO Pei, ZHANG Xue-lei. Performance of Direct Air-Cooled Condenser Under Windy Conditions and Its Influencing Factors[J]. Electric Power, 2013, 46(11): 113-118.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.2013.11.113.5

https://www.electricpower.com.cn/CN/Y2013/V46/I11/113

参考文献

[1] 王楠,白建华,张风营,等. 煤炭产区大力发展空冷机组的必要性与可行性研究[J]. 中国电力,2008,41（2）：8-10.
WANG Nan, BAI Jian-hua, ZHANG Feng-ying, et al . Study on necessity and feasibility to promote the development of air-cooled units in coal-rich regions [J]. Electric Power, 2008, 41(2): 8-10.
[2] 张晓鲁,汪建平,胡振岭. 600 MW火电机组空冷技术的研发与工程示范[J]. 中国电力,2011,44（3）：64-68.
ZHANG Xiao-lu, WANG Jian-ping, HU Zhen-ling. Research and demonstration of direct air-cooling system for 600 MW fossil-fired power plants [J]. Electric Power, 2011, 44(3): 64-68.
[3] 周兰欣,白中华,李卫华,等. 自然风对空冷凝汽器换热效率影响的数值模拟[J]. 动力工程,2008,28（1）：104-107.
ZHOU Lan-xin, BAI Zhong-hua, LI Wei-hua, et al . Numerical simulation for the effects of natural wind on heat exchange efficiency of air-cooled condenser[J]. Journal of Power Engineering, 2008, 28(1): 104-107.
[4] 周兰欣,白中华,李卫华. 直接空冷机组空冷岛结构优化研究[J]. 汽轮机技术,2008,50（2）：95-97.
ZHOU Lan-xin, BAI Zhong-hua, LI Wei-hua. Optimization on structure of air cooling platform of direct air cooling units [J].Turbine Technology, 2008, 50(2): 95-97.
[5] 周兰欣,崔皓程,魏春枝. 空冷平台间距对空冷凝汽器换热效率的影响[J]. 动力工程,2009,29（8）：765-776.
ZHOU Lan-xin, CUI Hao-cheng, WEI Chun-zhi. Effects of platform pitch on heat exchange efficiency of air-cooled condenser [J]. Journal of Power Engineering, 2009, 29(8): 765-776.
[6] 周兰欣,李建波,李卫华,等. 直接空机组凝汽器加装下挡风墙的数值模拟[J]. 动力工程,2008,28（5）：744-747.
ZHOU Lan-xin, LI Jian-bo, LI Wei-hua, et al . Numerical simulation of direct air cooling units’ condenser added lower wind break [J]. Journal of Power Engineering, 2008, 28(5): 744-747.
[7] 赵万里,刘沛清. 环境风对直接空冷系统塔下热回流影响的试验研究[J]. 动力工程,2008,28（3）：390-394.
ZHAO Wan-li, LIU Pei-qing. Experimental researches of the effect of environmental wind on thermal recirculation under the tower of direct air cooled system [J]. Journal of Power Engineering, 2008, 28(3): 390-394.
[8] 杨建国,刘达,张兆营,等. 加装导流以改善横向风对直接空冷凝汽器的影响[J]. 中国电机工程学报,2012,32（2）：1-8.
YANG Jian-guo, LIU Da, ZHANG Zhao-ying, et al . Effects of using wind guiding nets to improve prevailing ambient wind on direct air-cooled condensers[J]. Proceedings of the CSEE, 2012, 32(2): 1-8.
[9] 何伟峰,戴义平,马庆中. 环境风对空冷单元运行性能影响的数值研究[J]. 中国电机工程学报,2011,31（20）：13-18.
HE Wei-feng, DAI Yi-ping, MA Qing-zhong. Numerical study on the performance of an air-cooled condenser cell under wind influence [J]. Proceedings of the CSEE, 2011, 31(20): 13-18.
[10] VAN ROOYENN J A, KROGER D G. Performance trends of an air-cooled steam condenser under windy conditions [J]. Journal of Engineering for Gas Turbines and Power, 2008, 130(2): 023001-023006.
[11] VAN ROOYENN J A, KROGER D G. Performance trends of an air-cooled steam condenser under windy conditions [D]. Stellenbosch: University of Stellenbosch, 2007.
[12] BREDELL J R. Numerical investigation of fan performance in a forced draft air-cooled steam condenser[D]. Stellenbosch: University of Stellenbosch, 2005.
[13] OWEN M T F, KROGER D G. An investigation of air-cooled steam condenser performance under windy conditions using computation fluid dynamics[D]. Stellenbosch: University of Stellenbosch, 2010.
[14] 张学镭,王金平,陈海平. 环境风影响下直接空冷机组排汽压力的计算模型[J]. 中国电机工程学报,2012,32（23）：40-47.
ZHANG Xue-lei, WANG Jin-ping, CHEN Hai-ping. A calculation model of exhaust pressure of direct air-cooled units considering the effect of environmental wind[J]. Proceedings of the CSEE, 2012,32（23）：40-47.

[1]	张顺, 王振国, 姜文东, 徐枫, 段忠东. 特高压输电塔龙卷风荷载特性的数值模拟[J]. 中国电力, 2023, 56(10): 153-163.
[2]	刘周斌, 朱涛, 姜巍, 张晓波, 王炯耿, 管茜茜, 张秋实, 赵庆良. 储能锂离子电池包冷却系统的数值模拟与结构优化[J]. 中国电力, 2023, 56(10): 202-210.
[3]	潘晓伟, 彭烁, 李硕, 周贤, 王长军, 刘峻, 王瑞元. 余热锅炉烟气低温余热回收塔流场均匀性研究[J]. 中国电力, 2022, 55(3): 159-166.
[4]	雷嗣远, 李海浩, 李乐田, 倪贵东, 孔凡海, 吴国勋, 卞子君. SCR脱硝低负荷投运烟气调温旁路改造设计[J]. 中国电力, 2019, 52(9): 179-184.
[5]	陈海杰, 马务, 刘贡祎, 高攀. W火焰锅炉SNCR脱硝及其对SCR入口流场的影响[J]. 中国电力, 2019, 52(7): 146-153.
[6]	闫俊伏, 赵学斌. SCR催化剂的磨损试验与数值模拟研究[J]. 中国电力, 2019, 52(5): 170-175.
[7]	肖育军, 邹毅辉, 李彩亭, 周雪斌. SCR系统结构模型与数值模型的适用性分析[J]. 中国电力, 2019, 52(3): 146-152,160.
[8]	刘含笑, 陈招妹, 郭高飞, 王剑波, 崔盈, 孟银灿, 刘美玲. 烟气脱汞活性炭干粉喷射实验及喷射效果数值模拟[J]. 中国电力, 2019, 52(10): 138-143,170.
[9]	佘晓利, 潘卫国, 王程瑶, 倪迎春, 秦岭. 脱硫废水旁路塔雾化蒸发数值模拟[J]. 中国电力, 2019, 52(1): 129-136.
[10]	周玲妹, 张冠军, 朱宪然, 李皓宇, 焦开明. 600 MW机组锅炉掺烧劣质煤技术经济性研究[J]. 中国电力, 2018, 51(9): 1-7.
[11]	雷鉴琦. 降低燃煤机组SCR脱硝系统催化剂磨损的流场优化[J]. 中国电力, 2018, 51(7): 152-156,169.
[12]	杨来顺, 徐明海, 陈秋实. 管式除雾器开孔对除雾性能影响的数值模拟研究[J]. 中国电力, 2018, 51(7): 178-184.
[13]	叶侠丰, 丁红蕾, 潘卫国, 潘衍行. 带拓展面椭圆管束的换热、积灰及磨损特性研究[J]. 中国电力, 2018, 51(6): 26-32.
[14]	翁卫国, 孙建国, 李钦武, 周灿, 蒋善行. 脱硫废水零排放系统关键参数数值模拟研究[J]. 中国电力, 2018, 51(6): 42-47.
[15]	邱桂芝, 张志刚, 宋寅, 郭婷婷, 王海刚, 贾嘉, 王鹤麒. 管束式除雾器结构优化数值模拟及高效除雾器研制[J]. 中国电力, 2018, 51(5): 134-140.

环境风对直接空冷凝汽器性能的影响及主导因素分析

Performance of Direct Air-Cooled Condenser Under Windy Conditions and Its Influencing Factors

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

模态框（Modal）标题

环境风对直接空冷凝汽器性能的影响及主导因素分析

Performance of Direct Air-Cooled Condenser Under Windy Conditions and Its Influencing Factors

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics