余热锅炉烟气低温余热回收塔流场均匀性研究

doi:10.11930/j.issn.1004-9649.202102090

中国电力 ›› 2022, Vol. 55 ›› Issue (3): 159-166.DOI: 10.11930/j.issn.1004-9649.202102090

余热锅炉烟气低温余热回收塔流场均匀性研究

潘晓伟¹, 彭烁², 李硕¹, 周贤², 王长军¹, 刘峻¹, 王瑞元¹

1. 华能北京热电有限责任公司，北京 100023;
2. 中国华能集团清洁能源技术研究院有限公司，北京 102209

收稿日期:2021-02-15 修回日期:2021-05-10 出版日期:2022-03-28 发布日期:2022-03-29
作者简介:彭烁（1987—），男，通信作者，博士，从事火电厂烟气余热利用与城市智慧供热研究，E-mail：s_peng@qny.chng.com.cn
基金资助:
国家重点研发计划资助项目（CO₂近零排放的煤气化发电系统物质与能量协同优化研究，2017 YFB0601901）

Research on the Uniformity of Flow Field in the Low-Temperature Waste Heat Recovery Tower of Waste Heat Boiler Flue Gas

PAN Xiaowei¹, PENG Shuo², LI Shuo¹, ZHOU Xian², WANG Changjun¹, LIU Jun¹, WANG Ruiyuan¹

1. Huaneng Beijing Thermal Power Co., Ltd., Beijing 102209, China;
2. State Key Laboratory of Coal-Based Clean Energy, Beijing 102209, China

Received:2021-02-15 Revised:2021-05-10 Online:2022-03-28 Published:2022-03-29
Supported by:
This work is supported by National Key Research and Development Program of China (Collaborative Optimization of Mass and Energy in Coal Gasification Power Generation System with Near Zero CO₂ Emission, No.2017 YFB0601901)

摘要/Abstract

摘要： 烟气余热回收塔能通过塔内气-水换热过程，回收烟气显热和水蒸气汽化潜热，降低机组排烟温度，并且回收大量冷凝水。塔内空气动力场均匀性在很大程度上影响余热回收塔冷却性能，本文以某电厂逆流余热回收塔为研究对象，对入口导流板及布风板对塔内空气动力场均匀性的影响进行数值模拟研究，结果表明：增加布风板后，在布风板V型板出口，形成多股较小气流，起到整流均布作用；在布风板基础上继续增加入口导流板，余热回收塔内流场均匀性得到进一步改善，可保证布风板V型板入口气流速度分布均匀；增加布风板会增加余热回收塔流动损失，在布风板基础上继续增加入口导流板，余热回收塔流动损失会得到适当减小。

关键词: 余热回收塔, 流场, 均匀性, 数值模拟

Abstract: The packed waste heat absorption tower can recover the sensible heat of the flue gas and latent heat of vaporization through the gas-water heat exchange process in the tower. Then the exhaust temperature is reduced, and a large amount of condensed water is recovered. The uniformity of the aerodynamic field in the tower greatly affects the cooling performance of the waste heat recovery tower. This article focuses on the counterflow waste heat recovery tower of a power plant. The influence of the inlet baffle and air distribution plate on the uniformity of the aerodynamic field in the tower is carried out. The results show that, adding the air distribution plate, multiple smaller air flows are formed at the exit of the V-shaped plate of the air distribution plate, which plays a role of rectification and uniform distribution. The uniformity of the flow field in the waste heat recovery tower has been further improved if increasing the inlet deflector on the basis of the air distribution plate. The waste heat recovery Tower flow loss will be increased when adding the air distribution plate. The flow loss of the waste heat recovery tower will be appropriately reduced when increasing the inlet baffle on the basis of the air distribution plate.

Key words: Waste heat recovery tower, Flow field, Uniformity, Numerical simulation

潘晓伟, 彭烁, 李硕, 周贤, 王长军, 刘峻, 王瑞元. 余热锅炉烟气低温余热回收塔流场均匀性研究[J]. 中国电力, 2022, 55(3): 159-166.

PAN Xiaowei, PENG Shuo, LI Shuo, ZHOU Xian, WANG Changjun, LIU Jun, WANG Ruiyuan. Research on the Uniformity of Flow Field in the Low-Temperature Waste Heat Recovery Tower of Waste Heat Boiler Flue Gas[J]. Electric Power, 2022, 55(3): 159-166.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.202102090

https://www.electricpower.com.cn/CN/Y2022/V55/I3/159

参考文献

[1] ESPATOLERO S, CORTES C, FAGERSTRÖM J. Optimization of boiler cold-end and integration with the steam cycle in supercritical units[J]. Applied Energy, 2010, 87(5): 1651–1660.
[2] WESTERLUND L, HERMANSSON R, FAGERSTROEM J. Flue gas purification and heat recovery: A biomass fired boiler supplied with an open absorption system[J]. Applied Energy, 2012, 96(2): 444–450.
[3] 赵金姊, 赵玺灵, 王静贻, 等. 基于喷淋换热的燃煤锅炉烟气余热回收系统建模及模型验证[J]. 制冷学报, 2017, 38(6): 39–45
ZHAO Jinzi, ZHAO Xiling, WANG Jingyi, et al. Establishing and validating a model of waste-heat recovery system for coal-fired boilers based on spray tower[J]. Journal of Refrigeration, 2017, 38(6): 39–45
[4] 刘华, 周贤, 付林. 烟气与水冷凝换热影响因素实验研究[J]. 暖通空调, 2015, 45(7): 90–95
LIU Hua, ZHOU Xian, FU Lin. Experimental research on influence factors of direct-contact flue-gas-water condensation heat exchange[J]. Heating Ventilating & Air Conditioning, 2015, 45(7): 90–95
[5] 刘华, 周贤, 付林. 接触式烟气冷凝换热器的换热性能[J]. 暖通空调, 2014, 44(9): 97–100
LIU Hua, ZHOU Xian, FU Lin. Heat transfer performance of direct-contact flue-gas condensation heat exchanger[J]. Heating Ventilating & Air Conditioning, 2014, 44(9): 97–100
[6] LI H W, DUAN W B, WANG S B, et al. Numerical simulation study on different spray rates of three-area water distribution in wet cooling tower of fossil-fuel power station[J]. Applied Thermal Engineering, 2018, 130: 1558–1567.
[7] CHASSEM H, MARYAM K, SHAHRAM D. Numerical simulation of counter-flow wet-cooling towers[J]. International Journal of Refrigeration, 2009, 32: 996–1002.
[8] CHEN X H, SUN F Z, CHEN Y L, et al. Novel method for improving the cooling performance of natural draft wet cooling towers[J]. Applied Thermal Engineering, 2019, 147: 562–570.
[9] 陈友良. 基于控风和导流机理的湿式冷却塔内部空气动力场的优化与重构[D]. 济南: 山东大学, 2013.
CHEN Youliang. Optimization and reconstruction of the aerodynamic field in wet cooling tower based on wind control and guide mechanism [D]. Jinan: Shandong University, 2013.
[10] 赵振国, 石金玲, 魏庆鼎, 等. 自然风对空冷塔的不利影响及其改善措施[J]. 应用科学学报, 1998, 16(1): 112–120
ZHAO Zhenguo, SHI Jinling, WEI Qingding, et al. The engineering improvement for weakening the bad effect of natural wind on the dry cooling towers[J]. Journal of Applied Sciences, 1998, 16(1): 112–120
[11] 翟志强, 朱克勤, 符松. 横向风对自然通风干式冷却塔空气流场影响的模型实验研究[J]. 实验力学, 1997, 12(2): 306–311
ZHAI Zhiqiang, ZHU Keqin, FU Song. Model experiment for the influence of cross-wind on the air flow field in natural draft dry-cooling tower[J]. Journal of Experimental Mechanics, 1997, 12(2): 306–311
[12] 张晓东, 郑永刚, 王清照. 空冷塔内外流场的数值分析[J]. 热能动力工程, 2000, 15(1): 52–54
ZHANG Xiaodong, ZHENG Yonggang, WANG Qingzhao. Numerical analysis of external flow field in air cooling tower[J]. Journal of Engineering for Thermal Energy and Power, 2000, 15(1): 52–54
[13] 唐革风, 苏铭德, 符松. 横向风影响下空冷塔内外流场的数值研究[J]. 空气动力学学报, 1997, 15(3): 328–336
TANG Gefeng, SU Mingde, FU Song. Numerical study on flow field of a dry-cooling tower in a cross wind[J]. Acta Aerodynamica Sinica, 1997, 15(3): 328–336
[14] 谭小卫, 刘文浩, 刘桂雄. 逆流式冷却塔内部空气流场特性数值模拟与分析[J]. 自动化与信息工程, 2016, 37(4): 8–12
TAN Xiaowei, LIU Wenhao, LIU Guixiong. Numerical simulation and analysis of air flow field characteristics in countercurrent cooling tower[J]. Automation & Information Engineering, 2016, 37(4): 8–12
[15] 张群力, 张晓月, 曹明凯. 直接接触式烟气冷凝余热回收装置性能实验研究[J]. 暖通空调, 2020, 50(6): 124–128
ZHANG Qunli, ZHANG Xiaoyue, CAO Mingkai. Experimental study on performance of a direct contact flue gas condensing waste heat recovery device[J]. Journal of HV& AC, 2020, 50(6): 124–128
[16] 齐大伟, 李泽龙, 吴斌. 气液直接接触式大型气体冷凝冷却塔的工艺优化设计[J]. 天津化工, 2020, 34(4): 70–73
QI Dawei, LI Zelong, WU Bin. Process optimization design of large gas condensing cooling tower with direct gas-liquid contact[J]. Tianjin Chemical Industry, 2020, 34(4): 70–73
[17] 姚征, 陈康民. CFD通用软件综述[J]. 上海理工大学学报, 2002, 24(2): 137–144
YAO Zheng, CHEN Kangmin. Review on the commercial CFD softwares[J]. Journal of University of Shanghai for Science and Technology, 2002, 24(2): 137–144
[18] 周超, 谢七月, 左毅, 等. 基于多模型切换的锅炉主蒸汽温度预测控制[J]. 电力科学与技术学报, 2020, 35(4): 154–160
ZHOU Chao, XIE Qiyue, ZUO Yi, et al. Multi-model switching based predictive control for main steam temperature in boiler[J]. Journal of Electric Power Science and Technology, 2020, 35(4): 154–160
[19] 徐芙蓉, 平恒, 姜柏卿, 等. 三河电厂二期工程SCR 脱硝装置流场的模型试验和数值分析[J]. 热力发电, 2007(11): 28–32
XU Furong, PING Heng, JIANG Boqing, et al. Model test and numerical analysis of flow field in SCR denitrification unit of Sanhe power plant phase II[J]. Thermal Power Generation, 2007(11): 28–32
[20] 毛剑宏, 宋浩, 吴卫红, 等. 电站锅炉SCR脱硝系统导流板的设计与优化[J]. 浙江大学学报(工学版), 2011, 45(6): 1124–1129
MAO Jianhong, SONG Hao, WU Weihong, et al. Design and optimization of splitters in SCR system for coal fired boiler[J]. Journal of Zhejiang University (Engineering Science), 2011, 45(6): 1124–1129
[21] 张彦军, 高翔, 骆仲泱, 等. SCR脱硝系统入口烟道设计模拟研究[J]. 热力发电, 2007, 36(1): 15–23
ZHANG Yanjun, GAO Xiang, LUO Zhongyang, et al. Design and simulation of inlet flue of SCR denitration system[J]. Thermal Power Generation, 2007, 36(1): 15–23
[22] 沈丹, 仲兆平, 过小玲. 600 MW电厂SCR烟气脱硝反应器内不同导流板的流场数值模拟[J]. 电力环境保护, 2007, 23(1): 42–45
SHEN Dan, ZHONG Zhaoping, GUO Xiaoling. Numerical simulation of different guide plates in selective catalytic reduction denitrification reactor of 600 MW power plant[J]. Electric Power Environmental Protection, 2007, 23(1): 42–45

余热锅炉烟气低温余热回收塔流场均匀性研究

Research on the Uniformity of Flow Field in the Low-Temperature Waste Heat Recovery Tower of Waste Heat Boiler Flue Gas

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	张小坤, 吕大伟, 尹中强, 申双林, 王绍荣. 平板型固体氧化物燃料电池内温度分布规律[J]. 中国电力, 2023, 56(6): 123-131.
[2]	张顺, 王振国, 姜文东, 徐枫, 段忠东. 特高压输电塔龙卷风荷载特性的数值模拟[J]. 中国电力, 2023, 56(10): 153-163.
[3]	刘周斌, 朱涛, 姜巍, 张晓波, 王炯耿, 管茜茜, 张秋实, 赵庆良. 储能锂离子电池包冷却系统的数值模拟与结构优化[J]. 中国电力, 2023, 56(10): 202-210.
[4]	李满, 韩敬钦, 李陆军, 赵顺安. 660 MW机组间接空冷主辅共塔方案影响分析[J]. 中国电力, 2020, 53(5): 155-163.
[5]	雷嗣远, 李海浩, 李乐田, 倪贵东, 孔凡海, 吴国勋, 卞子君. SCR脱硝低负荷投运烟气调温旁路改造设计[J]. 中国电力, 2019, 52(9): 179-184.
[6]	陈海杰, 马务, 刘贡祎, 高攀. W火焰锅炉SNCR脱硝及其对SCR入口流场的影响[J]. 中国电力, 2019, 52(7): 146-153.
[7]	闫俊伏, 赵学斌. SCR催化剂的磨损试验与数值模拟研究[J]. 中国电力, 2019, 52(5): 170-175.
[8]	肖育军, 邹毅辉, 李彩亭, 周雪斌. SCR系统结构模型与数值模型的适用性分析[J]. 中国电力, 2019, 52(3): 146-152,160.
[9]	王方勇, 李文杰. W型锅炉SCR脱硝装置积灰原因分析与治理[J]. 中国电力, 2019, 52(2): 178-184.
[10]	刘含笑, 陈招妹, 郭高飞, 王剑波, 崔盈, 孟银灿, 刘美玲. 烟气脱汞活性炭干粉喷射实验及喷射效果数值模拟[J]. 中国电力, 2019, 52(10): 138-143,170.
[11]	佘晓利, 潘卫国, 王程瑶, 倪迎春, 秦岭. 脱硫废水旁路塔雾化蒸发数值模拟[J]. 中国电力, 2019, 52(1): 129-136.
[12]	周玲妹, 张冠军, 朱宪然, 李皓宇, 焦开明. 600 MW机组锅炉掺烧劣质煤技术经济性研究[J]. 中国电力, 2018, 51(9): 1-7.
[13]	雷鉴琦. 降低燃煤机组SCR脱硝系统催化剂磨损的流场优化[J]. 中国电力, 2018, 51(7): 152-156,169.
[14]	杨来顺, 徐明海, 陈秋实. 管式除雾器开孔对除雾性能影响的数值模拟研究[J]. 中国电力, 2018, 51(7): 178-184.
[15]	叶侠丰, 丁红蕾, 潘卫国, 潘衍行. 带拓展面椭圆管束的换热、积灰及磨损特性研究[J]. 中国电力, 2018, 51(6): 26-32.

模态框（Modal）标题

余热锅炉烟气低温余热回收塔流场均匀性研究

Research on the Uniformity of Flow Field in the Low-Temperature Waste Heat Recovery Tower of Waste Heat Boiler Flue Gas

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics