回料阀内气固两相流动特性的数值研究

doi:10.11930/j.issn.1004-9649.2013.7.1.4

中国电力 ›› 2013, Vol. 46 ›› Issue (7): 1-5.DOI: 10.11930/j.issn.1004-9649.2013.7.1.4

• 发电 • 下一篇

回料阀内气固两相流动特性的数值研究

王庆功, 杨海瑞, 吕俊复

清华大学热能工程系热科学与动力工程教育部重点实验室,北京 100084

收稿日期:2013-04-12 出版日期:2013-07-23 发布日期:2015-12-10
作者简介:王庆功（1988—）,男,河南汤阴人,博士研究生,从事洁净煤燃烧技术研究。
基金资助:
国家科技支撑计划项目（2012BAA02B01）

Numerical Study on Gas-Solid Flow Characteristics in Loop Seal

WANG Qing-gong, YANG Hai-rui, LU Jun-fu

Key Laboratory for Thermal Science and Power Engineering of Ministry of Education, Department of Thermal Engineering,Tsinghua University, Beijing 100084, China

Received:2013-04-12 Online:2013-07-23 Published:2015-12-10

摘要/Abstract

摘要： 为揭示回料阀内的负压差粘性滑移流动特性,基于浓相颗粒动力学理论,建立欧拉-欧拉模型对回料阀内的气固两相流动进行数值模拟研究,通过改变回料阀流化风和松动风风速、颗粒循环流率及回料腿出口背压等条件,详细分析了各工况下回料阀内的颗粒浓度分布、压力分布及气体反窜特征等,揭示了回料阀中的气固两相流动结构和变化特点。结果表明,回料阀中存在气体反窜现象;流化风和松动风风速越高,形成的气泡越多,气体反窜率越大;增加颗粒循环流率,颗粒携带气体现象更显著,气体反窜率减小;每增加返料腿出口背压1 000 Pa,料高增加约0.06 m,逆压差流动阻力增加,气体反窜率增加。

关键词: 回料阀, 流动特性, 数值模拟, 气体反窜

Abstract: Two-dimensional simulations of a pilot scale loop seal are mainly performed in this paper to reveal the viscous slip flow characteristics in negative pressure gradient. An Eulerian-Eulerian approach with constitutive relationships based on the kinetic theory of granular flow (KTGF) for dense gas-solid flows is used. By changing the fluidized-air/loose-air velocities, the particle circulation rate and the back pressure at the return leg, the flow characteristics including the distributions of particle concentration and pressure as well as the gas inverse flow phenomenon are carefully analyzed, thus the gas-solid flow structure and its variations are demonstrated. The results show that the gas inverse flow phenomenon does exist in loop seals. The higher velocity of fluidized-air or loose-air, the more bubble will come up with higher gas inverse flow rate. By increasing the particle circulation rate, particles will carry more air, resulting in the reduction of the gas inverse flow rate. By every 1 000 Pa increase of the back pressure, the packed height of the particles in the standpipe will rise by about 0.06 m and the gas reverse flow rate will also increase as a result of more flow resistance in negative pressure gradient.

Key words: loop seal, flow characteristic, numerical simulation, gas inverse flow phenomenon

中图分类号:

TK229.6

王庆功, 杨海瑞, 吕俊复. 回料阀内气固两相流动特性的数值研究[J]. 中国电力, 2013, 46(7): 1-5.

WANG Qing-gong, YANG Hai-rui, LU Jun-fu. Numerical Study on Gas-Solid Flow Characteristics in Loop Seal[J]. Electric Power, 2013, 46(7): 1-5.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.2013.7.1.4

https://www.electricpower.com.cn/CN/Y2013/V46/I7/1

参考文献

[1] 冯俊凯,岳光溪,吕俊复. 循环流化床燃烧锅炉[M]. 北京：中国电力出版社,2003.
[2] CHENG L, BASU P, CEN K. Solid circulation rate prediction in a pressurized loop seal[J]. Chem. Eng. Res. Des., 1998, 76(6): 761-763.
[3] CHENG L, BASU P. Effect of pressure on loop seal operation for a pressurized circulating fluidized bed[J]. Power Technol., 1999, 103(13): 203-211.
[4] BASU P, CHENG L. An analysis of loop seal operations in a circulating fluidized Bed[J]. Chem. Eng. Res. Des., 2000, 78(7): 991-998.
[5] KURAMOTO M, KUNII D, FURUSAWA T. Flow of dense fluidized particles through an opening in a circulation system [J]. Power Technol., 1986, 47(2): 141-149.
[6] 杨雪平. CFB炉膛风帽区域与回料阀内两相流动特性的研究[D]. 上海：上海交通大学,2009.
[7] DING J, GIDASPOW D. A bubbling fluidization model using kinetic theory of granular flow[J]. AIChE J., 1990, 36(4): 523-538.
[8] BENYAHIA S, ARASTOOPOUR H, KNOWLTON T M, et al . Simulation of particles and gas flow behavior in the riser section of a circulating fluidized bed using the kinetic theory approach for the particulate phase[C]//Proceedings of the Advanced Technology for Particle Processing. AIChE, New York, 1998.
[9] HILTUNEN K, JÄSBERG A, KALLIO S, et al . Multiphase flow dynamics: theory and numerics [M]. VTT Publications, VTT, 2009: 722.
[10] SCHAEFFER D G. Instability in the evolution equations describing incompressible granular flow[J]. J. Diff. Equations, 1987, 66:19-50.
[11] JOHNSON P C, JACKSON R. Frictional-collisional constitutive relations for granular materials, with application to plane shearing [J]. J. Fluid Mech., 1987, 176: 67-93.
[12] LU H L, GIDASPOW D, BOUILLARD J, et al . Hydrodynamic simulation of gas-solid flow in a riser using kinetic theory of granular flow [J]. Chem. Eng. J., 2003, 95(1-3): 1-13.
[13] SYAMLAL M, ROGERS W, O’BRIEN T J. MFIX documentation: Volume 1, Theory Guide[M]. National Technical Information Service, Springfield, 1993.
[14] GIDASPOW D. Multiphase flow and fluidization-continuum and kinetic theory descriptions [M]. Academic Press, 1994.
[15] WEN C Y, YU Y H. Mechanics of fluidization[J]. Chem. Eng. Prog. Symp. Ser., 1966, 62(62): 100-111.
[16] ERGUN S. Fluid flow through packed columns[J]. Chem. Eng. Prog., 1952, 48(2): 89-94.

回料阀内气固两相流动特性的数值研究

Numerical Study on Gas-Solid Flow Characteristics in Loop Seal

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	张顺, 王振国, 姜文东, 徐枫, 段忠东. 特高压输电塔龙卷风荷载特性的数值模拟[J]. 中国电力, 2023, 56(10): 153-163.
[2]	刘周斌, 朱涛, 姜巍, 张晓波, 王炯耿, 管茜茜, 张秋实, 赵庆良. 储能锂离子电池包冷却系统的数值模拟与结构优化[J]. 中国电力, 2023, 56(10): 202-210.
[3]	潘晓伟, 彭烁, 李硕, 周贤, 王长军, 刘峻, 王瑞元. 余热锅炉烟气低温余热回收塔流场均匀性研究[J]. 中国电力, 2022, 55(3): 159-166.
[4]	雷嗣远, 李海浩, 李乐田, 倪贵东, 孔凡海, 吴国勋, 卞子君. SCR脱硝低负荷投运烟气调温旁路改造设计[J]. 中国电力, 2019, 52(9): 179-184.
[5]	陈海杰, 马务, 刘贡祎, 高攀. W火焰锅炉SNCR脱硝及其对SCR入口流场的影响[J]. 中国电力, 2019, 52(7): 146-153.
[6]	闫俊伏, 赵学斌. SCR催化剂的磨损试验与数值模拟研究[J]. 中国电力, 2019, 52(5): 170-175.
[7]	肖育军, 邹毅辉, 李彩亭, 周雪斌. SCR系统结构模型与数值模型的适用性分析[J]. 中国电力, 2019, 52(3): 146-152,160.
[8]	刘含笑, 陈招妹, 郭高飞, 王剑波, 崔盈, 孟银灿, 刘美玲. 烟气脱汞活性炭干粉喷射实验及喷射效果数值模拟[J]. 中国电力, 2019, 52(10): 138-143,170.
[9]	佘晓利, 潘卫国, 王程瑶, 倪迎春, 秦岭. 脱硫废水旁路塔雾化蒸发数值模拟[J]. 中国电力, 2019, 52(1): 129-136.
[10]	周玲妹, 张冠军, 朱宪然, 李皓宇, 焦开明. 600 MW机组锅炉掺烧劣质煤技术经济性研究[J]. 中国电力, 2018, 51(9): 1-7.
[11]	雷鉴琦. 降低燃煤机组SCR脱硝系统催化剂磨损的流场优化[J]. 中国电力, 2018, 51(7): 152-156,169.
[12]	杨来顺, 徐明海, 陈秋实. 管式除雾器开孔对除雾性能影响的数值模拟研究[J]. 中国电力, 2018, 51(7): 178-184.
[13]	叶侠丰, 丁红蕾, 潘卫国, 潘衍行. 带拓展面椭圆管束的换热、积灰及磨损特性研究[J]. 中国电力, 2018, 51(6): 26-32.
[14]	翁卫国, 孙建国, 李钦武, 周灿, 蒋善行. 脱硫废水零排放系统关键参数数值模拟研究[J]. 中国电力, 2018, 51(6): 42-47.
[15]	邱桂芝, 张志刚, 宋寅, 郭婷婷, 王海刚, 贾嘉, 王鹤麒. 管束式除雾器结构优化数值模拟及高效除雾器研制[J]. 中国电力, 2018, 51(5): 134-140.

模态框（Modal）标题

回料阀内气固两相流动特性的数值研究

Numerical Study on Gas-Solid Flow Characteristics in Loop Seal

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics