IGBT器件封装用有机硅凝胶宽频介电特性与温度影响

doi:10.11930/j.issn.1004-9649.202007124

摘要/Abstract

摘要： 有机硅凝胶材料作为IGBT器件封装用绝缘材料，在器件的运行工况下，器件承受着重复性导通关断电压，对应频谱宽，且器件损耗将引起温度升高。为了能够准确分析器件内部电场特性，运用频域介电谱技术对有机硅凝胶在宽频、宽温度范围内的介电特性进行研究，利用叉指电极，实现对有机硅凝胶在不同温度下的宽频介电谱测试。采用Cole-Cole介电模型对实验数据进行拟合，并分析温度对Cole-Cole模型特征参量的影响规律。研究结果表明：频率和温度对有机硅凝胶的介电特性均有较大影响，在低频高温下，有机硅凝胶材料相对复介电常数的实部、虚部都显著增加。在所提取的Cole-Cole介电模型的特征参量中，直流电导率σ₀及特征参量Δε₁与温度之间的关系都满足Arrhenius方程，热活化能分别为0.233 eV与0.691 eV；弛豫时间τ₁和τ₂随温度的变化规律有所不同，但在高温时都明显增加。对半导体器件封装用有机硅凝胶材料介电特性的认知可以为器件内部电场分析和绝缘设计提供基础数据支撑。

关键词: 有机硅凝胶, 宽频介电谱, 温度, Cole-Cole模型, 特征参量

Abstract: Silicone gel materials are used as packaging material for IGBT devices. Under the operating conditions, the devices are subjected to a repetitive on-off voltage which corresponds to the wide spectrum, and the device loss will cause temperature rise. In order to accurately analyze the internal electric field characteristics of the devices, the dielectric properties of silicone gel in a wide temperature range were studied by frequency domain dielectric spectroscopy. The broadband dielectric spectroscopy of silicone gel at different temperatures was achieved by using interdigital electrodes. Then the Cole-Cole dielectric model was adopted to fit the experimental data, and the influence of temperature on the characteristic parameters of the Cole-Cole model was analyzed. The results showed that frequency and temperature have a great influence on the dielectric properties of silicone gel in the frequency domain. At low frequency and high temperature, the real and imaginary parts of the complex permittivity of silicone gel materials increase significantly. In the Cole-Cole dielectric model, the relationship between DC conductivity σ₀, space charge polarization intensity Δε₁ and the temperature are governed by the Arrhenius equation, and the thermal activation energy is 0.233 eV and 0.691 eV, respectively. The relaxation time τ₁ and τ₂ are different at low temperature and increase obviously at high temperature. The recognition of dielectric properties of silicone gel materials for semiconductor device encapsulation can provide basic data support for internal electric field analysis and insulation design of devices.

Key words: silicone gel, broadband dielectric properties, temperature, Cole-Cole model, characteristic parameter

毛塬, 李学宝, 顼佳宇, 赵志斌, 崔翔. IGBT器件封装用有机硅凝胶宽频介电特性与温度影响[J]. 中国电力, 2020, 53(12): 45-54.

MAO Yuan, LI Xuebao, XU Jiayu, ZHAO Zhibin, CUI Xiang. Broadband Dielectric Properties and Temperature Effects of Silicone Gel for IGBT Device Encapsulation[J]. Electric Power, 2020, 53(12): 45-54.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.202007124

https://www.electricpower.com.cn/CN/Y2020/V53/I12/45

参考文献

[1] 赵志斌, 邓二平, 张朋, 等. 换流阀用与直流断路器用压接型IGBT器件差异分析[J]. 电工技术学报, 2017, 32(19): 125-133
ZHAO Zhibin, DENG Erping, ZHANG Peng, et al. Review of the difference between the press pack IGBT using for converter valve and for DC breaker[J]. Transactions of China Electrotechnical Society, 2017, 32(19): 125-133
[2] FU P Y, ZHAO Z B, LI X B, et al. Partial discharge measurement and analysis in PPIs[J]. IET Power Electronics, 2019, 12(1): 138-146.
[3] FU P Y, ZHAO Z B, CUI X, et al. Partial discharge measurement and analysis in high voltage IGBT modules under DC voltage[J]. CSEE Journal of Power and Energy Systems, 2018, 4(4): 513-523.
[4] 章坚, 叶全明. 双组分加成型硅橡胶电子灌封料的制备[J]. 有机硅材料, 2009, 23(1): 31-35
ZHANG Jian, YE Quanming. Preparation of two-part addition cure potting silicone rubber[J]. Silicone Material, 2009, 23(1): 31-35
[5] 邓二平, 赵志斌, 张朋, 等. 压接型IGBT器件内部压力分布[J]. 电工技术学报, 2017, 32(6): 201-208
DENG Erping, ZHAO Zhibin, ZHANG Peng, et al. Clamping force distribution within press pack IGBTs[J]. Transactions of China Electrotechnical Society, 2017, 32(6): 201-208
[6] Data Sheet, Doc. No. 5SYA 1450-03 11-2017[EB/OL].http://search.abb.com/library/Download.aspx?DocumentID=5SYA%201450&LanguageCode=en&DocumentPartId=&Action=Launch.
[7] 解海峰, 巨军政. 有机硅凝胶灌封高压电器元件工艺研究[J]. 粘接, 2007, 28(4): 49-50
XIE Haifeng, JU Junzheng. Technical study of encapsulating high-voltage electrical apparatus with silicone gel material[J]. Adhesion in China, 2007, 28(4): 49-50
[8] 曹江. 介质材料电磁参数测量综述[J]. 宇航计测技术, 1994, 14(3): 30-34
CAO Jiang. A review on measurement of electromagnetic parameters of materials[J]. Journal of Astronautic Metrology and Measurement, 1994, 14(3): 30-34
[9] DO M T, AUGE J L, LESAINT O. Dielectric losses and breakdown in silicone gel[C]//IEEE Conference on Electrical Insulation and Dielectric Phenomena, 2006.
[10] LOCATELLI M L, KHAZAKA R, DIAHAM S, et al. Evaluation of encapsulation materials for high-temperature power device packaging[J]. IEEE Transactions on Power Electronics, 2014, 29(5): 2281-2288.
[11] 王昭, 刘曜宁. BaTiO₃复合硅胶对IGBT模块内部电场分布的影响[J]. 电子元件与材料, 2016, 35(12): 67-70
WANG Zhao, LIU Yaoning. Influences of BaTiO₃ composite silicone gel on electric field distribution in IGBT modules[J]. Electronic Components & Materials, 2016, 35(12): 67-70
[12] 杨丽君, 高思航, 高竣, 等. 油纸绝缘频域介电谱的修正Cole-Cole模型特征参量提取及水分含量评估方法[J]. 电工技术学报, 2016, 31(10): 26-33
YANG Lijun, GAO Sihang, GAO Jun, et al. Characteristic parameters extracted from modified cole-cole model and moisture content assessment methods study on frequency-domain dielectric spectroscopy of oil-paper insulation[J]. Transactions of China Electrotechnical Society, 2016, 31(10): 26-33
[13] 张大宁, 刘孝为, 詹江杨, 等. 变压器油纸绝缘频域介电谱的虚部分析[J]. 电工技术学报, 2019, 34(4): 847-854
ZHANG Daning, LIU Xiaowei, ZHAN Jiangyang, et al. Analysis of imaginary part of frequency domain spectroscopy for oil-paper insulation transformer[J]. Transactions of China Electrotechnical Society, 2019, 34(4): 847-854
[14] 李长云, 郝爱东. 机-热协同老化对纤维素绝缘纸频域介电谱特性的影响[J]. 电工技术学报, 2019, 34(17): 3705-3712
LI Changyun, HAO Aidong. Influence of the mechanical-thermal aging on the frequency-domain dielectric spectroscopy of cellulose insulation paper[J]. Transactions of China Electrotechnical Society, 2019, 34(17): 3705-3712
[15] 吴广宁, 钟鑫, 包健康. 温度对油纸绝缘介电频谱特性的影响[J]. 高电压技术, 2015, 41(12): 4081-4088
WU Guangning, ZHONG Xin, BAO Jiankang. Effect of temperature on dielectric spectrum characteristic of oil-paper insulation[J]. High Voltage Engineering, 2015, 41(12): 4081-4088
[16] 张涛, 李林多, 冉华军, 等. 采用改进Davidson-Cole介电模型的变压器油纸绝缘状态分析[J]. 电力自动化设备, 2019, 39(1): 192-197, 204
ZHANG Tao, LI Linduo, RAN Huajun, et al. Analysis of transformer oil paper insulation aging using improved Davidson-Cole dielectric model[J]. Electric Power Automation Equipment, 2019, 39(1): 192-197, 204
[17] 温福新, 董明, 任明, 等. 基于修正的Havriliak-Negami模型的SiO₂纳米改性变压器油宽频介电弛豫特性[J]. 电工技术学报, 2016, 31(7): 166-172
WEN Fuxin, DONG Ming, REN Ming, et al. The broadband dielectric relaxation properties of the transformer oil based on SiO₂ nanoparticles using modified havriliak-negami model[J]. Transactions of China Electrotechnical Society, 2016, 31(7): 166-172
[18] 潘斌, 程放, 高铁成. 现场监测胶粘剂热压固化的介电分析法[J]. 木材加工机械, 2011, 22(5): 7-10
PAN Bin, CHENG Fang, GAO Tiecheng. A dielectric analysis for in situ cure monitoring during wood-based panel hot-pressing[J]. Wood Processing Machinery, 2011, 22(5): 7-10
[19] 潘斌, 孙华林, 程放, 等. 人造板胶黏剂热压固化的介电监测技术开发[J]. 木材工业, 2012, 26(1): 20-23
PAN Bin, SUN Hualin, CHENG Fang, et al. In-situ dielectric observation of adhesive curing behavior during the wood-based panel hot-pressing process[J]. China Wood Industry, 2012, 26(1): 20-23
[20] 董帅. 基于阻抗法的茶油掺伪快速检测平台设计及鉴别试验[D]. 长沙: 中南林业科技大学, 2019.
Dong Shuai. Design and identification test of rapid detection platform for adulteration of tea oil based on impedance method[D]. Changsha: Central South University of forestry science and technology, 2019.
[21] 陈季丹, 刘子玉. 电介质物理学[M]. 北京: 机械工业出版社, 1982.
[22] 钟力生. 工程电介质物理与介电现象[M]. 西安: 西安交通大学出版社, 2013.
[23] JONSCHER A K. Dielectric relaxation in solids[J]. Journal of Physics D: Applied Physics, 1999, 32(14): R57-R70.
[24] 周利军, 李先浪, 王东阳, 等. 基于Havriliak-Negami介电弛豫模型的油纸绝缘状态评估[J]. 高电压技术, 2016, 42(1): 153-162
ZHOU Lijun, LI Xianlang, WANG Dongyang, et al. Status assessment of oil-paper insulation based on havriliak-negami dielectric relaxation model[J]. High Voltage Engineering, 2016, 42(1): 153-162
[25] GmbH&Co. KG. Interdigitated Electrodes Owner’s Manual[EB/OL]. http://WWW.novocontrol.de.
[26] WANG Z J, ZHOU W Y, SUI X Z, et al. Dielectric studies of al nanoparticle reinforced epoxy resin composites[J]. Polymer Composites, 2018, 39(3): 887-894.
[27] 张征平, 郝长金, 涂小涛, 等. 大型发电机主绝缘的Cole-Cole模型频域介电温度特性研究[J]. 电工电能新技术, 2016, 35(6): 29-35
ZHANG Zhengping, HAO Changjin, TU Xiaotao, et al. Study on frequency domain dielectric temperature characteristic of large generator insulation based on Cole-Cole model[J]. Advanced Technology of Electrical Engineering and Energy, 2016, 35(6): 29-35
[28] TSANGARIS G M, PSARRAS G C, TSANGARIS G M. Electric modulus and interfacial polarization in composite polymeric systems[J]. Journal of Materials Science, 1998, 33(8): 2027-2037.
[29] A.K.琼克. 固体中的介电弛豫(影印版)[M]. 西安: 西安交通大学出版社, 2008.
[30] PATHMANATHAN K, JOHARI G P. Dipolar and conductivity relaxations in LiCl-propylene glycol systems[J]. The Journal of Chemical Physics, 1991, 95(8): 5990-5998.
[31] WAN W T, YU D M, HE J, et al. Simultaneously improved toughness and dielectric properties of epoxy/core-shell particle blends[J]. Journal of Applied Polymer Science, 2008, 107(2): 1020-1028.
[32] 杨丽君, 齐超亮, 邓帮飞, 等. 采用修正Cole-Cole模型提取油纸绝缘频域介电谱的特征参量方法[J]. 高电压技术, 2013, 39(2): 310-317
YANG Lijun, QI Chaoliang, DENG Bangfei, et al. Application of modified cole-cole model to extract characteristics of frequency dielectric spectroscopy of oil-paper insulation[J]. High Voltage Engineering, 2013, 39(2): 310-317
[33] SINGH B K, KUMAR B. Impedance analysis and high temperature conduction mechanism of flux grown Pb(Zn_1/3Nb_2/3)_0.91Ti_0.09O₃ single crystal[J]. Crystal Research and Technology, 2010, 45(10): 1003-1011.