Research on the Impacts of Gas-steam Combined Cycle Air-inlet Cooling System on Unit Performance

doi:10.11930/j.issn.1004-9649.201809102

Abstract

Abstract: Taking PG9171E gas-steam combined cycle power plant as the research object, in this paper the combined cycle and intake cooling systems were modelled. The performance changes of the gas turbine side, the heat recovery steam generator side and the steam turbine side of the unit with the inlet cooling system were then analyzed. The results showed that for every 10 degrees of the temperature rise, the output of the E-type combined cycle unit with the intake cooling system will increase by about 9% while the efficiency of the heat recovery steam generator is reduced by 3%. In addition, by properly tuning steam parameters and taking full advantage of the waste heat resources the steam turbine will generate more output by about 2.1MW and the combined cycle efficiency can be improved by about 0.3%.

Key words: gas-steam combined cycle, intake cooling, combined cycle, heat recovery steam generator, gas turbine

CLC Number:

TK12

ZHANG Gaoqiang, FU Zhongguang, WANG Shucheng, ZHANG Tianqing. Research on the Impacts of Gas-steam Combined Cycle Air-inlet Cooling System on Unit Performance[J]. Electric Power, 2018, 51(12): 36-41.

Add to citation manager EndNote|Ris|BibTeX

URL: https://www.electricpower.com.cn/EN/10.11930/j.issn.1004-9649.201809102

https://www.electricpower.com.cn/EN/Y2018/V51/I12/36

References 16

[1]	董帅. 燃气蒸汽联合循环底循环性能分析及参数优化研究[D]. 保定:华北电力大学, 2017.
[2]	阳婉. 燃气轮机废热吸收式制冷进气冷却系统设计[D]. 大连:大连理工大学, 2016.
[3]	张丹, 高顶云, 郭甲生, 等. 分布式能源系统燃气发电机组特性及选型原则[J]. 煤气与热力, 2013, 33(10):20-23. ZHANG Dan, GAO Dingyun, GUO Jiasheng, et al. Characteristics and selection principles of gas generator sets in distributed energy systems[J]. Gas & Heat, 2013, 33(10):20-23.
[4]	邵梦麟, 梁前超, 邬健. 燃气轮机发电机组协调控制系统仿真研究[J]. 燃气轮机技术, 2016, 29(1):48-53. SHAO Menglin, LIANG Qianchao, WU Jian. Simulation research on coordinated control system of gas turbine generator sets[J]. Gas Turbine Technology, 2016, 29(1):48-53.
[5]	朱斌帅, 张赟. 燃气轮机进气冷却系统对机组经济性的影响[J]. 热力发电, 2014, 43(3):5-8. ZHU Binshuai, ZHANG Yun. The influence of gas turbine inlet cooling system on unit economy[J]. Thermal Power Generation, 2014, 43(3):5-8.
[6]	徐亦淳. 燃气轮机进气冷却技术研究[J]. 上海节能, 2017(11):630-633. XU Yichun. Research on gas turbine inlet cooling technology[J]. Shanghai Energy Conservation, 2017(11):630-633.
[7]	陈仁贵, 王海波, 牛兵, 等. 燃气轮机进气降温幅度的研究[J]. 热能动力工程, 2016, 31(3):129-133. CHEN Rengui, WANG Haibo, NIU Bing, et al. Research on the cooling range of gas turbine intake[J]. Thermal Power Engineering, 2016, 31(3):129-133.
[8]	刘传鹏, 李国俊, 林文佺, 等. 环冷机余热回收与利用系统的能量分析[J]. 钢铁, 2015, 50(12):60-66. LIU Chuanpeng, LI Guojun, LIN Wenquan, et al. Energy analysis of waste heat recovery and utilization system of ring cooler[J]. Iron & Steel, 2015, 50(12):60-66.
[9]	李云, 陈坚红, 盛德仁, 等. 大气参数对燃气轮机进气冷却效果的影响[J]. 机电工程, 2015, 32(4):566-570. LI Yun, CHEN Jianhong, SHENG Deren, et al. Influence of atmospheric parameters on gas turbine inlet cooling effect[J]. Mechanical & Electrical Engineering, 2015, 32(4):566-570.
[10]	李岩学, 阮应君, 刘青荣, 等. 基于烟气余热驱动喷射制冷的微型燃气轮机进气冷却系统[J]. 热力发电, 2015, 44(9):9-13. LI Yanxue, RUAN Yingjun, LIU Qingrong, et al. Micro-turbine intake cooling system based on flue gas residual heat driven injection refrigeration[J]. Thermal Power Generation, 2015, 44(9):9-13.
[11]	王晓瑜, 张冬洁, 徐建炎, 等. 余热锅炉结构形式及运行特性研究综述[J]. 中国有色冶金, 2012, 41(1):40-45. WANG Xiaoyu, ZHANG Dongjie, XU Jianyan, et al. Summary of research on structural form and operation characteristics of waste heat boiler[J]. China Nonferrous Metallurgy, 2012, 41(1):40-45.
[12]	梅映新, 刘明星, 杨洁. 进气冷却对燃气-蒸汽联合循环性能的影响[J]. 船电技术, 2015, 35(4):42-44
[13]	唐健, 崔耀欣, 张栋芳, 等. 燃气轮机进气冷却系统介绍及经济性分析[J]. 热力透平, 2014, 43(4):257-261. TANG Jian, CUI Yaoxin, ZHANG Dongfang, et al. Introduction and eonomic analysis of gas turbine inlet cooling system[J]. Thermal Turbine, 2014, 43(4):257-261.
[14]	裘浔隽, 杨瑜文, 林中达. 余热锅炉的动态数学模型及数字仿真[J]. 动力工程, 2002(6):2078-2083. QIU Xunjuan, YANG Yuwen, LIN Zhongda. Dynamic mathematical model and digital simulation of waste heat boiler[J]. Power Engineering, 2002(6):2078-2083.
[15]	胡舜锋. 余热制冷进气冷却的回热燃气轮机热力系统的研究[D]. 北京:中国科学院研究生院(工程热物理研究所), 2007.
[16]	焦树建. 论余热锅炉型联合循环中双压再热式余热锅炉的特性与汽轮机特性的优化匹配问题[J]. 燃气轮机技术, 2001(2):14-23. JIAO Shujian. On the optimization matching characteristics of steam turbine characteristics of dual pressure reheat waste heat boiler in waste heat boiler combined cycle[J]. Gas Turbine Technology, 2001(2):14-23.