陶瓷膜法的烟气水分及余热回收中试研究

doi:10.11930/j.issn.1004-9649.202010086

中国电力 ›› 2021, Vol. 54 ›› Issue (4): 199-206.DOI: 10.11930/j.issn.1004-9649.202010086

陶瓷膜法的烟气水分及余热回收中试研究

米大斌¹, 郭江龙², 张衡³

1. 河北建设投资集团有限责任公司, 河北石家庄 050001;
2. 河北冀研能源科学技术研究院有限公司, 河北石家庄 050001;
3. 华北电力大学能源动力与机械工程学院, 北京 102206

收稿日期:2020-10-22 修回日期:2021-01-22 发布日期:2021-04-23
作者简介:米大斌(1968-),男,硕士,高级工程师(教授级),从事火电厂节能减排研究,E-mail:midabin@jei.com.cn;张衡(1991-),男,通信作者,博士,讲师,从事火电厂烟气水分回收及脱硫废水处理研究,E-mail:zhangchongheng@ncepu.edu.cn
基金资助:
国家重点研发计划资助项目(2018YFB0604305)

Pilot Study of Flue Gas Moisture and Waste Heat Recovery Based on Ceramic Membrane Method

MI Dabin¹, GUO Jianglong², ZHANG Heng³

1. Hebei Construction & Investment Group Co., Ltd., Shijiazhuang 050001, China;
2. Hebei Ji-Yan Energy Science and Technology Research Institute Co., Ltd., Shijiazhuang 050001, China;
3. School of Energy, Power and Mechanical Engineering, North China Electric Power University, Beijing 102206, China

Received:2020-10-22 Revised:2021-01-22 Published:2021-04-23
Supported by:
This work is supported by the National Key Research and Development Program of China (No.2018YFB0604305)

摘要/Abstract

摘要： 为研究陶瓷膜在火电厂烟气水分及余热回收应用中的动态性能，在河北某330 MW燃煤电站采用40根微滤膜制作陶瓷膜组件，搭建中试装置，研究烟气流量和冷却水入口温度对水分和热量回收性能、潜热和显热释放情况的影响规律。研究结果表明，烟气流量为9 715 m³/h、冷却水入口温度为18.7 ℃时，膜组件的回收水量和热量分别可以达到43.65 kg/(m²·h)和106.31 MJ/(m²·h)。膜组件在真实的工业生产环境中展现出了良好的回收性能和极好的工业化应用潜力。

关键词: 陶瓷膜, 烟气, 水分回收, 汽化潜热, 中试

Abstract: In this paper, in order to study the dynamic performance of ceramic membrane in the applications of flue gas moisture and waste heat recovery in coal-fired power plants, a pilot apparatus was built in a 330 MW coal-fired power station in Hebei Province, in which the ceramic membrane module was integrated with 40 pipes of microfitration membrane. Then, the impacts of flue gas flow and cooling water inlet temperature on the moisture and heat recovery, as well as the latent heat and sensible heat release were studied. The study results show that with the flue gas flow at 9715 m³/h and the cooling water inlet temperature at 18.7 ℃, the moisture and heat recovered by the membrane module reach as much as 43.65 kg/(m²·h) and 106.31 MJ/(m²·h), respectively. The membrane modules have demonstrated remarkable recovery performance in actual industrial production environments and excellent potentials in industrial applications.

Key words: ceramic membrane, flue gas, moisture recovery, vaporization latent heat, pilot-scale test

米大斌, 郭江龙, 张衡. 陶瓷膜法的烟气水分及余热回收中试研究[J]. 中国电力, 2021, 54(4): 199-206.

MI Dabin, GUO Jianglong, ZHANG Heng. Pilot Study of Flue Gas Moisture and Waste Heat Recovery Based on Ceramic Membrane Method[J]. Electric Power, 2021, 54(4): 199-206.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.202010086

https://www.electricpower.com.cn/CN/Y2021/V54/I4/199

参考文献

[1] LI Z H, ZHANG H, CHEN H P, et al. Water vapor capture using microporous ceramic membrane[J]. Desalination, 2020, 482: 114405.
[2] 梁秀进,朱文韬,魏宏鸽,等. 燃煤机组烟气消白技术路线选择与经济分析[J]. 中国电力, 2019, 52(3): 16-22
LIANG Xiujin, ZHU Wentao, WEI Hongge, et al. Technical route selection and economic analysis on wet plume treatment for coal-fired units[J]. Electric Power, 2019, 52(3): 16-22
[3] 王琳,刘广建,陈海平. 燃煤电厂烟气湿烟羽消除技术[J]. 中国电力, 2019, 52(10): 162-170
WANG Lin, LIU Guangjian, CHEN Haiping. Wet plume removal technologies for coal-fired power plants[J]. Electric Power, 2019, 52(10): 162-170
[4] XIONG Y Y, TAN H Z, WANG Y B, et al. Pilot-scale study on water and latent heat recovery from flue gas using fluorine plastic heat exchangers[J]. Journal of Cleaner Production, 2017, 161: 1416-1422.
[5] KWANGKOOK J. Condensation of water vapor and sulfuric acid in boiler flue gas[D]. Bethlehem: Lehigh University, 2009.
[6] 兰俊杰. 火电厂排烟中水蒸汽的复合膜捕集技术研究[D]. 北京: 华北电力大学, 2013.
LAN Junjie. Research on the technology of capturing water vapor in flue gas of thermal power plant by composite membrane[D]. Beijing: North China Electric Power University, 2013.
[7] DU J R, SHI X Y, FENG X S, et al. Membrane gas dehydration in a pressure-electric coupled field[J]. Journal of Membrane Science, 2015, 493: 444-451.
[8] SIJBESMA H, NYMEIJER K, VAN MARWIJK R, et al. Flue gas dehydration using polymer membranes[J]. Journal of Membrane Science, 2008, 313(1/2): 263-276.
[9] 汪洋, 沈煜晖, 陶爱平, 等. 烟气膜法水分捕集技术的研究进展[J]. 电力科技与环保, 2013, 29(3): 13-14
WANG Yang, SHEN Yuhui, TAO Aiping, et al. Progress and prospect of study on water capture from flue gas technology[J]. Electric Power Technology and Environmental Protection, 2013, 29(3): 13-14
[10] LI Z H, ZHANG H, CHEN H P, et al. Experimental research on the heat transfer and water recovery performance of transport membrane condenser[J]. Applied Thermal Engineering, 2019, 160: 114060.
[11] LI Z H, XUE K L, ZHANG H, et al. Numerical investigation on condensation mode of the transport membrane condenser[J]. International Journal of Heat and Mass Transfer, 2020, 161: 120305.
[12] LIN C X, WANG D X, BAO A N. Numerical modeling and simulation of condensation heat transfer of a flue gas in a bundle of transport membrane tubes[J]. International Journal of Heat and Mass Transfer, 2013, 60: 41-50.
[13] WANG D X. Transport membrane condenser for water and energy recovery from power plant flue gas[R]. Des Plaines: Gas Technology Institute, 2012.
[14] WANG T T, YUE M W, QI H, et al. Transport membrane condenser for water and heat recovery from gaseous streams: performance evaluation[J]. Journal of Membrane Science, 2015, 484: 10-17.
[15] YUE M W, ZHAO S F, FERON P H M, et al. Multichannel tubular ceramic membrane for water and heat recovery from waste gas streams[J]. Industrial & Engineering Chemistry Research, 2016, 55(9): 2615-2622.
[16] CHEN H P, ZHOU Y N, CAO S T, et al. Heat exchange and water recovery experiments of flue gas with using nanoporous ceramic membranes[J]. Applied Thermal Engineering, 2017, 110: 686-694.
[17] 陈海平, 仲雅娟, 周亚男, 等. 复合膜法火电厂烟气捕水性能的实验研究[J]. 中国电力, 2015, 48(7): 63-67
CHEN Haiping, ZHONG Yajuan, ZHOU Yanan, et al. Experimental study on flue gas water recovery performance using composite membranes in thermal power plants[J]. Electric Power, 2015, 48(7): 63-67
[18] ZHOU Y N, CHEN H P, XIE T, et al. Effect of mass transfer on heat transfer of microporous ceramic membranes for water recovery[J]. International Journal of Heat and Mass Transfer, 2017, 112(1): 643-648.
[19] LI Z H, ZHANG H, CHEN H P. Application of transport membrane condenser for recovering water in a coal-fired power plant: a pilot study[J]. Journal of Cleaner Production, 2020, 261: 121229.
[20] LI Z H, MI D B, ZHANG H, et al. Experimental study on synergistic capture of fine particles and waste heat from flue gas using membrane condenser[J]. Energy, 2021, 217: 119392.

陶瓷膜法的烟气水分及余热回收中试研究

Pilot Study of Flue Gas Moisture and Waste Heat Recovery Based on Ceramic Membrane Method

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	姜龙, 程亮, 李金晶, 李庆. 燃煤电厂湿法脱硫浆液品质及喷淋层运行状况定量评价[J]. 中国电力, 2023, 56(11): 217-225, 235.
[2]	伊超, 滕达, 宋绍伟, 陈鸥. 喷淋法燃煤电站烟气冷凝水回收系统应用分析[J]. 中国电力, 2023, 56(11): 226-235.
[3]	刘广建, 岳凤站, 周硕, 王琳, 干雪. 燃煤电厂水平衡模型与节水分析[J]. 中国电力, 2022, 55(4): 221-228.
[4]	黄婧杰, 刘镂志, 殷旭锋, 李雪芹, 潘轩, 周任军. 碳循环利用的垃圾焚烧电厂-烟气处理-P2G协调优化运行[J]. 中国电力, 2022, 55(3): 152-158.
[5]	刘志坦, 姚杰, 庄柯, 喻乐蒙, 周凯. 燃气轮机与燃煤机组SCR脱硝催化剂特性比较[J]. 中国电力, 2021, 54(6): 145-152.
[6]	杜振, 王志东, 江建平, 朱跃. 湿法脱硫系统PM_2.5排放特性分析[J]. 中国电力, 2021, 54(6): 153-158.
[7]	李飞. 旋转雾化蒸发技术对脱硫废水和烟气的适应性研究[J]. 中国电力, 2021, 54(4): 213-220.
[8]	徐遵义, 刘文慧, 张旭冉, 张海燕. 基于数据驱动的浆液循环泵运行优化研究[J]. 中国电力, 2021, 54(3): 197-204.
[9]	张志强, 朱法华, 邹斯诣, 史鹏飞, 王晓玲, 游秦, 姚力, 闫绍帅, 王兴. 基于实测的烟气“消白”工程环境效益研究[J]. 中国电力, 2020, 53(9): 202-207.
[10]	王晋权, 赵周明, 张志华. 低温余热闪蒸脱硫废水处理系统设计及应用[J]. 中国电力, 2020, 53(8): 151-157,181.
[11]	刘文慧, 徐遵义, 张旭冉, 张海燕. 基于互信息和PCA理论的湿法烟气脱硫工况特征提取方法[J]. 中国电力, 2020, 53(8): 158-163.
[12]	滕达, 李铁林, 李昂, 安连锁, 陈海平, 沈国清. 电站锅炉尾部烟气余热回收与梯级利用系统特性分析[J]. 中国电力, 2020, 53(7): 189-196.
[13]	王淦, 王少权, 高翔, 郦建国, 周林海, 冯国华, 章成伟, 陈铁炯. 湿烟羽消除中过热度的影响因素分析[J]. 中国电力, 2020, 53(6): 179-184.
[14]	王卫群, 张磊, 黄治军, 傅高健, 李国奇. 基于CFD模拟计算的SCR脱硝系统喷氨优化试验方法[J]. 中国电力, 2020, 53(6): 185-190.
[15]	齐萌, 赵毅. 催化氧化法脱除燃煤烟气中的单质汞[J]. 中国电力, 2020, 53(3): 147-153,166.

模态框（Modal）标题

陶瓷膜法的烟气水分及余热回收中试研究

Pilot Study of Flue Gas Moisture and Waste Heat Recovery Based on Ceramic Membrane Method

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics