电站锅炉尾部烟气余热回收与梯级利用系统特性分析

doi:10.11930/j.issn.1004-9649.201909089

中国电力 ›› 2020, Vol. 53 ›› Issue (7): 189-196.DOI: 10.11930/j.issn.1004-9649.201909089

• 燃煤机组水分回收及处理关键技术专栏 • 上一篇下一篇

电站锅炉尾部烟气余热回收与梯级利用系统特性分析

滕达, 李铁林, 李昂, 安连锁, 陈海平, 沈国清

华北电力大学能源动力与机械工程学院，北京 102206

收稿日期:2019-09-10 修回日期:2020-02-20 发布日期:2020-07-05
作者简介:滕达(1992—)，男，通信作者，博士研究生，从事燃煤发电机组烟气余热与水分高效低成本回收及处理关键技术研究与应用，E-mail：tengda8013@163.com
基金资助:
国家重点研发计划资助项目(燃煤发电机组水分高效低成本回收及处理关键技术研究与应用，2018YFB0604305-05)

System Characteristic Analysis of Waste Heat Recovery and Cascade Utilization of Tail Flue Gas of Power Boiler

TENG Da, LI Tielin, LI Ang, AN Liansuo, CHEN Haiping, SHEN Guoqing

School of Energy, Power and Mechanical Engineering, North China Electric Power University, Beijing 102206, China

Received:2019-09-10 Revised:2020-02-20 Published:2020-07-05
Supported by:
This work is supported by National Key Research and Development Program of China (Research and Application of Key Technologies for High Efficiency and Low Cost Water Recovery and Treatment of Coal-fired Generating Units, No.2018YFB0604305)

摘要/Abstract

摘要： 燃煤电站锅炉实际运行排烟温度一般在130~150 ℃，进一步回收烟气余热有利于降低发电煤耗，减少污染物排放。针对电站锅炉尾部不同位置烟气参数不同的情况，设计了安装在空气预热器后及湿法脱硫装置后的两级热交换器余热回收系统，并结合330 MW燃煤电站锅炉，分析了不同负荷下，两级热交换器的换热量、冷凝水量、两侧介质静压差及发电标准煤耗降低值的变化情况，同时监测了二级热交换器前后烟气中固体颗粒物含量。结果表明：一级热交换器的换热量明显高于二级热交换器，烟气中水分主要在二级热交换器冷凝；标准煤耗降低值高达3.09 g/（kW·h）；同时烟气经过二级热交换器后固体颗粒物含量明显降低。为燃煤电站锅炉尾部烟气余热回收利用提供了参考。

关键词: 电站锅炉, 尾部烟气, 余热回收, 梯级利用, 热交换器, 发电煤耗

Abstract: The exhaust gas temperature of the power station boiler is generally 130~150 ℃. Further recovery of flue gas waste heat is beneficial for the reduction of coal consumption and pollutant emissions. Regarding the different flue gas parameters at various parts of the tail of the power station boiler, the waste heat recovery system is formulated with two-stage heat exchangers installed, i.e., one after the air preheater and the other after the wet desulfurization device. In consideration of the operation of the 330 MW coal-fired power station boiler, the effects of heat transfer, condensate and static pressure difference on both sides of the two-stage heat exchangers and the reduction of coal consumption for power generation were analyzed under different load conditions. Change of solid particulate matter in flue gas before and after heat exchanger was also monitored. The results show that the heat exchange capacity of the primary heat exchanger is significantly higher than that of the secondary heat exchanger, and the condensed water mainly occurs in the secondary heat exchanger. The standard coal consumption reduction value can reach up to 3.09 g/(kW·h). Besides, the content of solid particles in the flue gas after the heat exchanger is significantly reduced. This paper provides certain reference value for the waste heat recovery of flue gas from power station boilers.

Key words: power boiler, tail flue gas, waste heat recovery, cascade utilization, heat exchanger, coal consumption for generation

滕达, 李铁林, 李昂, 安连锁, 陈海平, 沈国清. 电站锅炉尾部烟气余热回收与梯级利用系统特性分析[J]. 中国电力, 2020, 53(7): 189-196.

TENG Da, LI Tielin, LI Ang, AN Liansuo, CHEN Haiping, SHEN Guoqing. System Characteristic Analysis of Waste Heat Recovery and Cascade Utilization of Tail Flue Gas of Power Boiler[J]. Electric Power, 2020, 53(7): 189-196.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.201909089

https://www.electricpower.com.cn/CN/Y2020/V53/I7/189

参考文献

[1] 国家统计局能源统计司. 中国能源统计年鉴: 2017 [M]. 北京: 中国统计出版社, 2017.
[2] 杨勇平, 杨志平, 徐钢, 等. 中国火力发电能耗状况及展望[J]. 中国电机工程学报, 2013, 33(23): 1-11, 15
YANG Yongping, YANG Zhiping, XU Gang, et al. Situation and prospect of energy consumption for China’s thermal power generation[J]. Proceedings of the CSEE, 2013, 33(23): 1-11, 15
[3] 陈海平, 刘彦达, 周亚男. 中空纤维膜法回收火电厂烟气中水蒸气[J]. 热力发电, 2017, 46(1): 100-105, 111
CHEN Haiping, LIU Yanda, ZHOU Yanan. Experimental study on recycling water vapor from flue gas of thermal power plants using hollow fiber membrane[J]. Thermal Power Generation, 2017, 46(1): 100-105, 111
[4] 吴华新. 低位烟气余热深度回收利用状况述评(Ⅱ): 传热过程与技术应用研究[J]. 热能动力工程, 2012, 27(4): 399-404, 415
WU Huaxin. Review of the status quo of low quality flue gas waste heat recovery and utilization(Ⅱ): study of the application of heat transfer[J]. Journal of Engineering for Thermal Energy and Power, 2012, 27(4): 399-404, 415
[5] 吴华新. 低位烟气余热深度回收利用状况述评(Ⅰ): 新技术路线与回收条件改变的影响[J]. 热能动力工程, 2012, 27(3): 271-276
WU Huaxin. Review of the application status of low quality flue gas waste heat utilization technologies(Ⅰ): remaining temperature conditions and heat recovery difficulties[J]. Journal of Engineering for Thermal Energy and Power, 2012, 27(3): 271-276
[6] WEI M L, FU L, ZHANG S G, et al. Experimental investigation on vapor-pump equipped gas boiler for flue gas heat recovery[J]. Applied Thermal Engineering, 2019, 147(25): 371-379.
[7] ZHANG X, YUAN J Q, CHEN Z X, et al. A dynamic heat transfer model to estimate the flue gas temperature in the horizontal flue of the coal-fired utility boiler[J]. Applied Thermal Engineering, 2018(135): 368-378.
[8] NIU Y, HUA J, FAN H M. Optimization of solution heat exchanger of AHP in flue gas waste heat recovery[J]. Procedia Engineering, 2017, 205: 477-484.
[9] WANG C J, HE B S, SUN S Y, et al. Application of a low pressure economizer for waste heat recovery from the exhaust flue gas in a 600 MW power plant[J]. Energy, 2012, 48(1): 196-202.
[10] ZAHEED L, JACHUCK R J J. Review of polymer compact heat exchanges with special emphasis on a polymer film unit[J]. Applied Thermal Engineering, 2004, 24(16): 2323-2358.
[11] 胡亚才, 张雪东, 王建平, 等. 塑料换热技术在溴化锂吸收式制冷机上的应用展望[J]. 制冷学报, 2005, 26(1): 44-48
HU Yacai, ZHANG Xuedong, WANG Jianping, et al. Plastic heat transfer technology application prospect on lithium bromide-water absorption chillers[J]. Journal of Refrigeration, 2005, 26(1): 44-48
[12] 陈林, 孙颖颖, 杜小泽, 等. 回收烟气余热的特种耐腐蚀塑料换热器的性能分析[J]. 中国电机工程学报, 2014, 34(17): 2778-2783
CHEN Lin, SUN Yingying, DU Xiaoze, et al. Performance analysis of anti-corrosion heat exchangers made of special plastics for flue gas heat recovery[J]. Proceedings of the CSEE, 2014, 34(17): 2778-2783
[13] 刘宇钢, 易广宙. 燃煤发电机组锅炉余热利用系统探讨[J]. 中国电力, 2016, 49(10): 1-6
LIU Yugang, YI Guangzhou. Discussion on waste heat utilization system of coal-fired utility boilers[J]. Electric Power, 2016, 49(10): 1-6
[14] TERHAN M, COMAKLI K. Design and economic analysis of a flue gas condenser to recover latent heat from exhaust flue gas[J]. Applied Thermal Engineering, 2016, 100: 1007-1015.
[15] 付林, 田贯三, 隋军, 等. 吸收式热泵在燃气采暖冷凝热回收中的应用[J]. 太阳能学报, 2003, 24(5): 620-624
FU Lin, TIAN Guansan, SUI Jun, et al. Combining absorption heat pump with gas boiler for exhaust condensing heat recovery in district heating system[J]. Acta Energiae Solaris Sinica, 2003, 24(5): 620-624
[16] YANG B, JIANG Y, FU L, et al. Experimental and theoretical investigation of a novel full-open absorption heat pump applied to district heating by recovering waste heat of flue gas[J]. Energy and Buildings, 2018, 173: 45-57.
[17] 赵小楠, 杨巨生. 褐煤锅炉余热集成梯级利用系统的应用与研究[J]. 华电技术, 2017, 39(10): 66-68, 80
ZHAO Xiaonan, YANG Jusheng. Lignite boiler waste heat integrated gradient utilization system application and study[J]. Huadian Technology, 2017, 39(10): 66-68, 80
[18] 唐保金, 宗成璋, 薛永明, 等. 吸收式热泵技术在电厂烟气余热回收中的应用探讨[J]. 节能, 2016, 35(10): 65-67
TANG Baojin, ZONG Chengzhang, XUE Yongming, et al. Application of absorption heat pump technology in waste heat recovery of power plant flue gas[J]. Energy Conservation, 2016, 35(10): 65-67
[19] 常海青, 张燕. 锅炉烟气余热深度利用及减排技术的研究与应用[J]. 中国电力, 2016, 49(10): 43-48
CHANG Haiqing, ZHANG Yan. Research and application of in-depth boiler flue gas waste heat utilization and emission reduction technology[J]. Electric Power, 2016, 49(10): 43-48
[20] 林万超. 火电厂热系统节能理论 [M]. 西安: 西安交通大学出版社, 1994: 22-26.
[21] 徐钢, 许诚, 杨勇平, 等. 电站锅炉余热深度利用及尾部受热面综合优化[J]. 中国电机工程学报, 2013, 33(14): 1-8, 15
XU Gang, XU Cheng, YANG Yongping, et al. Deep utilization of exhaust heat and comprehensive optimization of tail heating surfaces for utility boilers[J]. Proceedings of the CSEE, 2013, 33(14): 1-8, 15

电站锅炉尾部烟气余热回收与梯级利用系统特性分析

System Characteristic Analysis of Waste Heat Recovery and Cascade Utilization of Tail Flue Gas of Power Boiler

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	侯建军, 付喜亮, 李染生, 刘贵喜, 孙燕平, 孙利, 梁占伟. 基于㶲分析的能量梯级利用供热变工况运行优化研究[J]. 中国电力, 2023, 56(8): 230-240.
[2]	张国柱, 张钧泰, 文钰, 杨凯旋, 刘明, 刘继平. 燃煤机组烟气余热及水回收系统变工况特性和调控策略[J]. 中国电力, 2022, 55(4): 214-220.
[3]	潘晓伟, 彭烁, 李硕, 周贤, 王长军, 刘峻, 王瑞元. 余热锅炉烟气低温余热回收塔流场均匀性研究[J]. 中国电力, 2022, 55(3): 159-166.
[4]	文贤馗, 李翔, 邓彤天, 钟晶亮, 王锁斌, 刘石. 先进压缩空气储能系统的余热回收和利用[J]. 中国电力, 2022, 55(2): 28-34.
[5]	梁占伟, 杨承刚, 张磊, 徐亚涛, 孙鹏, 张俊杰, 王顺森. 基于单耗理论的抽汽耦合高背压供热优化[J]. 中国电力, 2019, 52(12): 171-178.
[6]	刘贵锋, 韩雪松. 烟煤锅炉掺烧褐煤对机组安全经济性影响的研究[J]. 中国电力, 2018, 51(9): 46-52.
[7]	徐党旗, 侯逊, 姬海民, 张知翔, 周飞, 邹小刚, 赵治平. 暖风器集箱系统并联管组流量偏差因素的研究[J]. 中国电力, 2018, 51(2): 162-168.
[8]	尤良洲, 韩倩倩, 晋银佳, 朱跃. 火电企业水资源综合利用及污染防治技术路线探讨[J]. 中国电力, 2018, 51(10): 134-138.
[9]	关键, 项群扬, 沈利, 沈伟军, 裘立春. 省煤器给水旁路提升SCR进口烟温应用研究[J]. 中国电力, 2017, 50(9): 116-120.
[10]	黄兴德, 许琨, 杨心刚, 游喆, 赵泓. 锅炉高温受热面蒸汽氧化皮微观结构和剥落敏感性研究[J]. 中国电力, 2017, 50(8): 68-72.
[11]	王然, 张志刚, 安连锁. 基于新型测温技术的电站锅炉燃烧优化模型研究[J]. 中国电力, 2017, 50(5): 151-155.
[12]	吴昕, 潘福敏, 欧大生, 陈萍, 骆平平. 动力装置余热回收系统的性能和应用[J]. 中国电力, 2017, 50(2): 117-123.
[13]	张立栋, 李伟伟, 邵天成, 于婷俐, 周阳. 集流导叶对喷嘴射流刚性的影响[J]. 中国电力, 2017, 50(2): 95-100.
[14]	霍鹏，李千军，郑李坤. 火电机组吸收式热泵的余热回收加热凝补水经济性分析[J]. 中国电力, 2015, 48(5): 115-119.
[15]	李海山, 雎刚, 毛晓飞, 余廷芳. 基于智能计算的锅炉燃烧优化指导系统及其应用[J]. 中国电力, 2014, 47(7): 1-5.

模态框（Modal）标题

电站锅炉尾部烟气余热回收与梯级利用系统特性分析

System Characteristic Analysis of Waste Heat Recovery and Cascade Utilization of Tail Flue Gas of Power Boiler

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics