宽负荷下灵活二次再热超超临界锅炉调温特性研究

doi:10.11930/j.issn.1004-9649.201811131

中国电力 ›› 2019, Vol. 52 ›› Issue (4): 119-126.DOI: 10.11930/j.issn.1004-9649.201811131

宽负荷下灵活二次再热超超临界锅炉调温特性研究

许威, 张剑, 范浩杰, 张忠孝, 孙蔚婷

上海交通大学热能工程研究所, 上海 200240

收稿日期:2018-12-03 修回日期:2019-01-04 出版日期:2019-04-05 发布日期:2019-04-16
作者简介:许威(1994-),男,硕士研究生,从事超超临界及二次再热锅炉研究,E-mail:xu200902023@sjtu.edu.cn;张剑(1993-),男,博士研究生,从事超超临界及二次再热锅炉研究,E-mail:1136925837@qq.com;范浩杰(1969-),男,副教授,从事燃煤发电技术研究,E-mail:hjfan@sjtu.edu.cn;张忠孝(1959-),男,教授,从事燃煤发电技术研究,E-mail:zhangzhongxiao@sjtu.edu.cn
基金资助:
国家重点研发计划资助项目（2017YFB0602102）。

Study on Steam Temperature Regulation Characteristics in Flexible Ultra-supercritical Boiler with Double Reheat Cycle under Wide Loads

XU Wei, ZHANG Jian, FAN Haojie, ZHANG Zhongxiao, SUN Weiting

Institute of Thermal Energy Engineering, Shanghai Jiao Tong University, Shanghai 200240, China

Received:2018-12-03 Revised:2019-01-04 Online:2019-04-05 Published:2019-04-16
Supported by:
This work is supported by the National Key Research & Development Program of China (No.2017YFB0602102).

摘要/Abstract

摘要： 建立了二次再热锅炉的分室热力计算模型，并通过炉内高温受热面的对流传热量对炉膛出口烟气温度计算式进行修正，以国内某660 MW二次再热锅炉对模型进行验证。利用模型分别研究了摆动燃烧器、烟气挡板调节及烟气再循环对主汽温、一次和二次再热汽温的影响，得到了3种蒸汽的温度随不同调温方式变化的特性曲线。结果表明：主汽温对烟气再循环率的变化较敏感，烟气再循环率每增加1%，主汽温降低0.8℃；再热蒸汽温度对烟气挡板调节较敏感，前烟井挡板开度每增加1%，一次再热蒸汽温度上升1℃，二次再热蒸汽温度降低1.7℃。

关键词: 燃煤电厂, 二次再热锅炉, 热力计算模型, 汽温特性, 摆动燃烧器, 烟气再循环, 烟气挡板

Abstract: A cell-divided model of double-reheat boilers for thermodynamic calculation is established, in which the formula of the gas temperature at the furnace outlet is revised by using the convective heat volume of high temperature heating surfaces in the furnace. The model is validated on a domestic 660 MW double-reheat boiler. Based on this model, the impacts of tilting burners, adjustment of gas dampers and gas recirculation on the steam temperatures are studied, and the characteristic curves of the steam temperature change with respect to various regulating methods are obtained. From the results it turned out that the main steam temperature is more sensitive to gas recirculation. For every 1% jump of the recirculation rate, the main steam temperature drops by 0.8 ℃. Besides, the reheat steam temperatures are more sensitive to gas damper adjustment. For every 1% increase of the damper opening in front flue, the primary-reheat steam temperature rises by 1 ℃, while the secondary-reheat steam temperature drops by 1.7 ℃.

Key words: coal-fired power plant, double-reheat boiler, thermodynamic calculation model, steam temperature characteristics, tilting burners, gas recirculation, gas damper

中图分类号:

TK222

许威, 张剑, 范浩杰, 张忠孝, 孙蔚婷. 宽负荷下灵活二次再热超超临界锅炉调温特性研究[J]. 中国电力, 2019, 52(4): 119-126.

XU Wei, ZHANG Jian, FAN Haojie, ZHANG Zhongxiao, SUN Weiting. Study on Steam Temperature Regulation Characteristics in Flexible Ultra-supercritical Boiler with Double Reheat Cycle under Wide Loads[J]. Electric Power, 2019, 52(4): 119-126.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.201811131

https://www.electricpower.com.cn/CN/Y2019/V52/I4/119

参考文献 19

[1]	张广才, 周科, 柳宏刚, 等. 某超临界600 MW机组直流锅炉深度调峰实践[J]. 热力发电, 2018, 47(5):83-88 ZHANG Guangcai, ZHOU Ke, LIU Honggang, et al. Practice of deep peak load regulation for a 600 MW supercritical concurrent boiler[J]. Thermal Power Generation, 2018, 47(5):83-88
[2]	徐星, 谭锐, 李永生, 等. 1000 MW超超临界二次再热机组一次调频方式分析[J]. 中国电力, 2018, 51(2):169-175 XU Xing, TAN Rui, LI Yongsheng, et al. Analysis on primary frequency regulation of 1000-MW double-reheat ultra-supercritical units[J]. Electric Power, 2018, 51(2):169-175
[3]	高昊天, 范浩杰, 董建聪, 等. 超超临界二次再热机组的发展[J]. 锅炉技术, 2014, 45(4):1-3, 33 GAO Haotian, FAN Haojie, DONG Jiancong, et al. Development of ultra supercritical unit with double reheat cycle[J]. Boiler Technology, 2014, 45(4):1-3, 33
[4]	侯玉婷, 周俊波, 高林, 等. 超超临界二次再热机组凝结水节流变负荷技术分析[J]. 热力发电, 2017, 46(8):82-85 HOU Yuting, ZHOU Junbo, GAO Lin, et al. Analysis on condensate throttling technology for ultra supercritical double-reheat thermal power units[J]. Thermal Power Generation, 2017, 46(8):82-85
[5]	张金营, 张秋生, 吕剑虹, 等. 超超临界二次再热机组再热汽温调节方案应用分析[J]. 中国电力, 2016, 49(7):77-81 ZHANG Jinying, ZHANG Qiusheng, LU Jianhong, et al. Analysis on the application of reheat steam temperature control strategy in ultra supercritical units with secondary reheat cycle[J]. Electric Power, 2016, 49(7):77-81
[6]	王月明, 牟春华, 姚明宇, 等. 二次再热技术发展与应用现状[J]. 热力发电, 2017, 46(8):1-10 WANG Yueming, MOU Chunhua, YAO Mingyu, et al. Review of the development and application of double-reheat power generation technology[J]. Thermal Power Generation, 2017, 46(8):1-10
[7]	胡尊民, 于国强, 殳建军, 等. 1000 MW二次再热机组汽温控制策略[J]. 华电技术, 2018, 40(5):33-37, 78 HU Zunmin, YU Guoqiang, SHU Jianjun, et al. Control strategy on steam temperature of 1000 MW double reheat units[J]. Huadian Technology, 2018, 40(5):33-37, 78
[8]	龙志云, 宋宝军. 烟气再循环份额对二次再热机组汽温的影响[J]. 电站系统工程, 2018, 34(3):21-22 LONG Zhiyun, SONG Baojun. Influence of flue gas recirculation rate on temperature of double-reheater unit[J]. Power System Engineering, 2018, 34(3):21-22
[9]	高伟, 宋宝军. 烟气再循环在二次再热锅炉中的应用探讨[J]. 电站系统工程, 2015, 31(3):79-80 GAO Wei, SONG Baojun. Discussion on flue gas recirculation for double reheat cycles boiler[J]. Power System Engineering, 2015, 31(3):79-80
[10]	杨新民, 吴恒运, 茅义军. 超超临界二次再热机组再热汽温的控制[J]. 中国电力, 2016, 49(1):19-22 YANG Xinmin, WU Hengyun, MAO Yijun. Reheat steam temperature control of an ultra supercritical unit with second reheat cycle[J]. Electric Power, 2016, 49(1):19-22
[11]	王林, 杨博, 高景辉, 等. 660 MW二次再热机组锅炉再热汽温调整[J]. 热力发电, 2017, 46(8):91-95 WANG Lin, YANG Bo, GAO Jinghui, et al. Adjustment on reheat steam temperature for a 660 MW double-reheat boiler[J]. Thermal Power Generation, 2017, 46(8):91-95
[12]	雷志伟. 基于改进型QPSO-MGPC的二次再热汽温约束控制策略[J]. 黑龙江电力, 2018, 40(2):130-136 LEI Zhiwei. Constrained control strategy of double reheat steam temperature system based on improved QPSO-MGPC[J]. Heilongjiang Electric Power, 2018, 40(2):130-136
[13]	李德龙. 百万等级超超临界二次再热机组锅炉特性研究[D]. 上海:上海交通大学, 2015.
[14]	樊泉桂. 超临界锅炉的汽温特性及控制[J]. 动力工程, 2007, 27(1):34-37 FAN Quangui. Study on characteristics and control of the steam temperature of supercritical boilers[J]. Journal of Power Engineering, 2007, 27(1):34-37
[15]	樊泉桂. 1000 MW超超临界锅炉中间点温度和汽温控制[J]. 动力工程, 2007, 27(3):332-335 FAN Quangui. Temperature at intermediate points of 1000 MW ultra-supercritical boilers and their steam temperature control[J]. Journal of Power Engineering, 2007, 27(3):332-335
[16]	樊晋元, 谢英柏. 超临界锅炉变压运行与传热特性的量化分析[J]. 锅炉技术, 2012, 43(5):1-5 FAN Jinyuan, XIE Yingbo. Quantitative analysis for characteristics in variable pressure operation and heat transfer in ultra supercritical boiler[J]. Boiler Technology, 2012, 43(5):1-5
[17]	樊泉桂, 阎维平, 闫顺林, 等. 锅炉原理[M]. 北京:中国电力出版社, 2008.
[18]	李传胜. 二次再热塔式锅炉再热蒸汽调温方式工程应用[J]. 热力发电, 2016, 45(8):68-74 LI Chuansheng. Engineering application of reheat steam temperature control mode for double-reheat tower boilers[J]. Thermal Power Generation, 2016, 45(8):68-74
[19]	王林, 刘辉, 刘超, 等. 1000 MW二次再热塔式炉省煤器汽化问题分析[J]. 节能技术, 2017, 35(6):509-513 WANG Lin, LIU Hui, LIU Chao, et al. The analysis of 1000 MW double reheat tower boiler economizer vaporization[J]. Energy Conservation Technology, 2017, 35(6):509-513

宽负荷下灵活二次再热超超临界锅炉调温特性研究

Study on Steam Temperature Regulation Characteristics in Flexible Ultra-supercritical Boiler with Double Reheat Cycle under Wide Loads

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 19

相关文章 15

编辑推荐

Metrics

[1]	刘含笑, 吴黎明, 赵琳, 于立元, 郦建国, 崔盈. 燃煤电厂湿式电除尘器减排及能效特性研究[J]. 中国电力, 2022, 55(5): 196-203.
[2]	孙尊强, 郑成航, 周灿, 王圣, 马修元, 叶毅科. 燃煤电厂典型除尘器运行现状分析及优化[J]. 中国电力, 2022, 55(11): 194-201.
[3]	吴家玉, 莫华, 胡耘, 朱杰, 帅伟, 张晴, 姜岸. 京津冀及周边地区燃煤电厂煤场无组织颗粒物不同控制情景下时空变化特征[J]. 中国电力, 2021, 54(2): 182-189.
[4]	赵宏, 张发捷, 马云龙, 马宝林, 唐潇, 徐仁博, 罗通达, 李成宝, 任传明, 于洁, 孙路石. 燃煤电厂SCR脱硝氨逃逸迁移规律试验研究[J]. 中国电力, 2021, 54(1): 196-202.
[5]	赵柄, 王海刚, 胡冬, 陈坤洋, 金绪良, 殷爱鸣. 燃煤电厂碱性吸附剂脱汞性能研究[J]. 中国电力, 2020, 53(9): 208-213.
[6]	姚燕, 马云龙, 杨晓宁, 张华东, 王丽朋. 高砷煤SCR脱硝催化剂中毒失活研究[J]. 中国电力, 2020, 53(6): 191-196.
[7]	马学礼, 孙希进, 苏燊燊, 张仁锋, 党立晨, 黄显昌, 谢永平. 基于超低排放的燃煤电厂烟囱高度优化研究[J]. 中国电力, 2020, 53(5): 179-184.
[8]	徐静馨, 朱法华, 王圣, 张明, 赵秀勇, 孙雪丽, 胡耘, 田文鑫. 超低排放燃煤电厂和燃气电厂综合对比[J]. 中国电力, 2020, 53(2): 164-172,179.
[9]	李滨, 杨阳. 烟气SO₃监测控制冷凝法采样方法[J]. 中国电力, 2020, 53(1): 140-146.
[10]	王文欣, 高毅, 刘春红, 童小忠, 陈彪, 祁志福, 张勤. 燃煤电厂旁路烟气干燥塔控制技术开发[J]. 中国电力, 2020, 53(1): 147-154.
[11]	雷嗣远, 李海浩, 李乐田, 倪贵东, 孔凡海, 吴国勋, 卞子君. SCR脱硝低负荷投运烟气调温旁路改造设计[J]. 中国电力, 2019, 52(9): 179-184.
[12]	许剑, 夏小飞, 李凯伦, 郑金, 王星, 马翔. 电站轴流引风机叶片通过频率振动超标问题机理分析及治理[J]. 中国电力, 2019, 52(7): 117-122.
[13]	陈海杰, 马务, 刘贡祎, 高攀. W火焰锅炉SNCR脱硝及其对SCR入口流场的影响[J]. 中国电力, 2019, 52(7): 146-153.
[14]	晋银佳, 刘泽宇, 尤良洲, 夏守庆, 唐国瑞. RESALT技术在燃煤电厂脱硫废水浓缩处理中的应用[J]. 中国电力, 2019, 52(7): 154-160.
[15]	王锡辉, 陈厚涛, 朱晓星, 王志杰, 盛锴. W火焰直流炉协调控制策略及工程应用优化[J]. 中国电力, 2019, 52(6): 154-159,165.

模态框（Modal）标题

宽负荷下灵活二次再热超超临界锅炉调温特性研究

Study on Steam Temperature Regulation Characteristics in Flexible Ultra-supercritical Boiler with Double Reheat Cycle under Wide Loads

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 19

相关文章 15

编辑推荐

Metrics