Application of the RESALT Technology in the FGD Wastewater Concentration Processing of Coal-Fired Power Plant

doi:10.11930/j.issn.1004-9649.201812121

Abstract

Abstract: RESALT technology which is developed based on the Electric dialysis (ED) technology can effectively separate calcium ions from sulfate ions such that the scaling of CaSO₄ is inhibited while the wastewater condensation process can be accomplished at the same time. The experiments were conducted in Huadian Laizhou power company with the inlet flow of the FGD wastewater about 3-4 m³/h. The RESALT equipments were tested to treat three kinds of flue gas desulfurization (FGD) wastewater. The results show that sulfate ions could be efficiently separated from calcium ions and the high salt contained wastewater could also be concentrated at the same time. Since there is no additional chemical agents required for the wastewater pre-treatment, electricity consumption is the main component of the cost during the wastewater treatment process, which will rise as the salt concentration of the wastewater goes up. For example, with the concentrations of 6 480 mg/L of SO₄^2-, 1 820 mg/L of Ca²⁺, 2 462 mg/L of Mg²⁺, 20 680 mg/L of Cl^- and 10 465 mg/L of Na⁺ in the FGD wastewater, the overall electricity consumption rate is 49.5 kW·h per ton and the direct treatment cost is about 22.6 RMB/ton.

Key words: coal-fired power plants, high salt concentration wastewater, FGD wastewater, quantity reduction, RESALT technology

CLC Number:

X511
TM621.9

JIN Yinjia, LIU Zeyu, YOU Liangzhou, XIA Shouqing, TANG Guorui. Application of the RESALT Technology in the FGD Wastewater Concentration Processing of Coal-Fired Power Plant[J]. Electric Power, 2019, 52(7): 154-160.

Add to citation manager EndNote|Ris|BibTeX

URL: https://www.electricpower.com.cn/EN/10.11930/j.issn.1004-9649.201812121

https://www.electricpower.com.cn/EN/Y2019/V52/I7/154

References

[1] 山东省环境保护局, 山东省质量技术监督局. 山东省半岛流域水污染综合排放标准:DB37/676—2007[S]. 2007.
[2] 晋银佳, 孙海峰, 王丰吉, 等. 燃煤电厂高盐废水"零排放"处理工艺及技术经济分析[J]. 华电技术, 2017, 39(12):46-49 JIN Yinjia, SUN Haifeng, WANG Fengji, et al. Technical and economic analysis of "zero emission" treatment of high salinity wastewater from coal-fired power plants[J]. Huadian Technology, 2017, 39(12):46-49
[3] 刘维锐. 高效结晶除硬技术处理高盐废水的研究[D]. 呼和浩特:内蒙古大学, 2014.
[4] 吴怡卫. 石灰石-石膏湿法烟气脱硫废水处理的研究[J]. 中国电力, 2006, 39(4):75-78 WU Yiwei. Study on the wastewater treatment in limestone-gymsum wet FGD process[J]. Electric Power, 2006, 39(4):75-78
[5] 袁俊生, 张涛, 刘杰, 等. 反渗透后高盐废水浓缩技术进展[J]. 水处理技术, 2015, 41(11):16-21 YUAN Junsheng, ZHANG Tao, LIU Jie, et al. Technical progress on the concentration of high salinity brine after RO process[J]. Technology of Water Treatment, 2015, 41(11):16-21
[6] 唐刚, 龙国庆. 卧式MVC蒸发/结晶处理电厂高含盐废水并回用[J]. 中国给水排水, 2013, 29(8):94-96 TANG Gang, LONG Guoqing. Treatment and reuse of high salinity wastewater from power plant by horizontal MVC evaporation/crystallization process[J]. China Water and Wastewater, 2013, 29(8):94-96
[7] 甄晓华. 工业浓盐水高回收率脱盐工艺研究[D]. 兰州:兰州交通大学, 2013.
[8] 王海, 张峰榛, 王成端, 等. MVR技术处理高盐废水工艺的模拟与分析[J]. 环境工程, 2015, 33(10):35-37 WANG Hai, ZHANG Fengzhen, WANG Chengduan, et al. Simulation and analysis of MVR technology in the treatment of hypersaline wastewater[J]. Environmental Engineering, 2015, 33(10):35-37
[9] 毛彦霞. 蒸汽机械再压缩技术处理含盐废水试验研究[D]. 重庆:重庆交通大学, 2014.
[10] 连坤宙, 陈景硕, 刘朝霞, 等. 火电厂脱硫废水微滤、反渗透膜法深度处理试验研究[J]. 中国电力, 2016, 49(2):148-152 LIAN Kunzhou, CHEN Jingshuo, LIU Zhaoxia, et al. Experimental study on the reduction treatment of desulfurization wastewater in power plants by membrane[J]. Electric Power, 2016, 49(2):148-152
[11] 刘亚鹏, 王金磊, 陈景硕, 等. 火电厂脱硫废水预处理工艺优化及管式微滤膜实验研究[J]. 中国电力, 2016, 49(2):153-158 LIU Yapeng, WANG Jinlei, CHEN Jingshuo, et al. Optimization of FGD wastewater pretreatment technique for thermal power plant and test studies on tubular crossflow microfiltration process[J]. Electric Power, 2016, 49(2):153-158
[12] 钱感, 关洪银. 燃煤电厂脱硫废水综合处理工艺[J]. 水处理技术, 2017, 43(2):136-138 QIAN Gan, GUAN Hongyin. Treatment technology of desulfurization wastewater in coal-fired power plant[J]. Technology of Water Treatment, 2017, 43(2):136-138
[13] 晋银佳, 王帅, 姬海宏, 等. 深度过滤-烟道蒸发处理脱硫废水的数值模拟[J]. 中国电力, 2016, 49(12):174-179 JIN Yinjia, WANG Shuai, JI Haihong, et al. Numerical simulation of desulfurization wastewater treatment with in-depth filtration-flue evaporation process[J]. Electric Power, 2016, 49(12):174-179
[14] 杨跃伞, 苑志华, 张净瑞, 等. 燃煤电厂脱硫废水零排放技术研究进展[J]. 水处理技术, 2017, 43(6):29-33 YANG Yuesan, YUAN Zhihua, ZHANG Jingrui, et al. Research progress of technologies for zero-discharge of desulfurization wastewater from coal-fired power plants[J]. Technology of Water Treatment, 2017, 43(6):29-33
[15] 张江涛, 曹红梅, 董娟, 等. 火电厂废水零排放技术路线比较及影响因素分析[J]. 中国电力, 2017, 50(6):120-124 ZHANG Jiangtao, CAO Hongmei, DONG Juan, et al. Comparison on the technical routes of zero liquid discharge of fossil-fired power plants and analysis on the influencing factors[J]. Electric Power, 2017, 50(6):120-124
[16] YIN N, ZHONG Z X, XING W H. Ceramic membrane fouling and cleaning in ultrafiltration of desulfurization wastewater[J]. Desalination, 2013, 319(10):92-98.
[17] AHMAD A L, YASIN N H M, DEREK C J C, et al. Crossflow microfiltration of microalgae biomass for biofuel production[J]. Desalination, 2012, 302:65-70.
[18] 刘海洋, 江澄宇, 谷小兵, 等. 燃煤电厂湿法脱硫废水零排放处理技术进展[J]. 环境工程, 2016, 34(4):33-36, 41 LIU Haiyang, JIANG Chengyu, GU Xiaobing, et al. Development of zero liquid discharge technologies for desulfurization wastewater from coal-fired power plant[J]. Environmental Engineering, 2016, 34(4):33-36, 41
[19] 刘宁. 燃煤电厂脱硫废水零排放技术[J]. 能源与节能, 2015(12):89-91 LIU Ning. On the technology for "zero-emissions" of desulfurization waste water in coal-fired power plant[J]. Energy and Energy Conservation, 2015(12):89-91
[20] 卢剑, 李亚娟, 许臻, 等. 海水直流冷却电厂烟气脱硫废水处理工艺的研究[J]. 中国电力, 2018, 51(11):179-184 LU Jian, LI Yajuan, XU Zhen, et al. Study on desulfurization wastewater treatment for the power plant with seawater cooling system[J]. Electric Power, 2018, 51(11):179-184