Application of Flue Gas Deep Cooling System in 1 000-MW Ultra-Supercritical Units

doi:10.11930/j.issn.1004-9649.2014.4.32.5

Abstract

Abstract: In order to fully utilize the waste heat from flue gas to heat up the condensate to realize the low-temperature dust removal with high efficiency in the electrostatic precipitator(ESP) through reducing the fly ash specific resistivity at lower flue gas temperatures, to improve the boiler efficiency and to reduce the heat consumption and gross coal consumption for power generation units, a flue gas waste heat recovery device is designed and installed between the air pre-heater outlet and the ESP inlet in a 1 000-MW boiler. Practical operation shows that with the flue gas deep cooling device installed, the ESP dust removal efficiency is increased by 0.1% while the desulfurization water consumption is lowered substantially and the net coal consumption is significantly decreased.

Key words: 1 000-MW unit, boiler in-depth cooler, exhaust gas temperature, net coal consumption rate

CLC Number:

TK223.3

DU He-chong, WU Ke-feng, SHEN Jian-dong, YUAN De-gang, LI Da-cai. Application of Flue Gas Deep Cooling System in 1 000-MW Ultra-Supercritical Units[J]. Electric Power, 2014, 47(4): 32-37.

Add to citation manager EndNote|Ris|BibTeX

URL: https://www.electricpower.com.cn/EN/10.11930/j.issn.1004-9649.2014.4.32.5

https://www.electricpower.com.cn/EN/Y2014/V47/I4/32

References

[1] 谢德勇. 3、4号机集控运行规程[R] . 广东大唐国际潮州发电有限责任公司,2010.
[2] 李秀平,李博,谢津伦. 燃煤锅炉低温余热利用技术应用分析[J]. 中国电力,2011,44（12）：86-88.
LI Xiu-ping, LI Bo, XIE Jin-lun. Application of low-temperature waste heat utilization technology in coal-fired boiler[J]. Electric Power, 2011, 44(12): 86-88.
[3] 王存洋. 潮州电厂4号机组低温省煤器运行技术标准[S]. 青岛达能环保公司,2012.
[4] 郭以永.深度降低660 MW超超临界机组锅炉排烟温度的可行性分析与实践[D]. 济南：山东大学,2011.
[5] 李鹏飞,佟会玲. 烟气酸露点计算方法比较和分析[J]. 锅炉技术,2009,40（6）：5-8.
LI Peng-fei, TONG Hui-ling. Comparison and analysis of boiler flue gas acid dew point calculation method [J]. Boiler Technology, 2009, 40(6): 5-8.
[6] 张基标,郝卫,赵之军,等. 锅炉烟气低温腐蚀的理论研究和工程实践[J]. 动力工程学报,2011,31（10）：730-734.
ZHANG Ji-biao, HAO Wei, ZHAO Zhi-jun, et al . Theoretical and practical research on mechanism of low-temperature corrosion caused by boiler flue gas[J]. Journal of Chinese Society of Power Engineering, 2011, 31(10): 730-734.
[7] 龙群力,朱彦雷,刘继平. 发电厂锅炉烟气余热回收方案热经济性研究[J]. 山东电力技术,2012（4）：63-65.
LONG Qun-li, ZHU Yan-lei, LIU Ji-ping. Thermal economy analysis on waste heat recovery of the exhaust flue gas of boiler in power plant [J]. Shandong Electric Power, 2012(4): 63-65.
[8] 刘鹤忠,连正权. 低温省煤器在火力发电厂中的运用探讨[J].电力勘测设计,2010（4）：32-38.
[9] 周武,向朝晟,李键. 火力发电厂锅炉尾部烟气余热利用技术[J]. 东方电气评论,2012, 26（1）：46-50.
ZHOU Wu, XIANG Chao-sheng, LI Jian. Heat recovery technology of boiler flue gas of thermal power plant[J]. Dongfang Electric Review, 2012, 26(1): 46-50.
[10] 杨少国,张红艳,任贵龙. 回热抽汽对上游级气动性能影响的数值研究[J]. 汽轮机技术,2010,52（2）：99-100.
YANG Shao-guo, ZHANG Hong-yan, REN Gui-long. Numerical investigation of effect of regenerative steam extraction on aerodynamic performance of the upsteam stage in a steam turbine[J]. Turbine Technology, 2010, 52(2): 99-100.
[11] 康晓妮,马文举,马涛,等. 320 MW机组锅炉加装低温省煤器的经济性研究[J]. 热力发电,2012,41（5）：8-11.
KANG Xiao-ni, MA Wen-ju, MA Tao, et al . Economic study on adding low-temperature economizer on a 320 MW unit [J]. Thermal Power Generation, 2012, 41(5): 8-11.
[12] 崔海鹏. 电站锅炉排烟温度高原因及其改进措施[D]. 北京：华北电力大学,2012.
[13] 王健,钟圣俊,靳鑫,等. 粉尘比电阻不同测试标准的对比分析[J]. 中国粉体技术,2012（10）：24-26.
WANG Jian, ZHONG Sheng-jun, JIN Xin, et al . Comparative analysis of different standards for testing dust resistivity [J]. China Powder Science and Technology, 2012(10): 24-26.
[14] 沈源,田春光. 广东大唐国际潮州发电有限责任公司4号炉烟气深度冷却热力性能试验报告[R]. 广东电网公司电力科学研究院,2012.
[15] 石鑫,林永君. 300 MW循环流化床锅炉炉管泄漏监测系统的研究[J]. 锅炉制造,2013（3）：9-10.
SHI Xin, LIN Yong-jun. Study on the boiler tube leakage monitoring system of 300 MW circulated fluidized bed boiler [J]. Boiler Manufacturing, 2013(3): 9-10.