高效脱硫协同除尘关键技术分析

doi:10.11930/j.issn.1004-9649.201802042

中国电力 ›› 2018, Vol. 51 ›› Issue (6): 37-41.DOI: 10.11930/j.issn.1004-9649.201802042

• 燃煤电站低成本超低排放技术专栏 • 上一篇下一篇

高效脱硫协同除尘关键技术分析

杜振, 魏宏鸽, 张杨, 朱跃

华电电力科学研究院有限公司, 浙江杭州 310030

收稿日期:2018-02-09 出版日期:2018-06-05 发布日期:2018-06-12
作者简介:杜振(1985-),男,工程师,硕士,从事电厂污染物控制技术的研究与应用,E-mail:adozn@163.com
基金资助:
国家重点研发计划资助项目（2016YFC0203704）。

Analysis on Key Technologies of High Efficiency Desulfurization and Collaborative Dust Removal

DU Zhen, WEI Hongge, ZHANG Yang, ZHU Yue

Huadian Electric Power Research Institute Co., Ltd., Hangzhou 310030, China

Received:2018-02-09 Online:2018-06-05 Published:2018-06-12
Supported by:
This work is supported by National Key Research and Development Program (No.2016YFC0203704).

摘要/Abstract

摘要： 为系统研究高效脱硫协同除尘技术，分析了已投运的高效脱硫协同除尘典型机组的实际应用情况，从而明确了高效脱硫协同除尘技术需同步考虑低低温电除尘技术和高效脱硫技术。低低温电除尘技术应严控烟温、灰硫比，并做好流场、流速设计及材质选择以防止烟气冷却器磨损泄漏；高效脱硫技术应优化塔内喷淋层和除雾器层流场、设置合理塔内设施间距和流速，并保证足够的喷淋覆盖率、配置合适的喷嘴和除雾器。通过低低温电除尘技术和高效脱硫技术的协同作用可有效地实现SO₂和烟尘的超低排放，因此“低低温电除尘技术+高效脱硫协同除尘技术”是烟尘和SO₂超低排放的一条优选技术路线。

关键词: 火力发电, 低低温电除尘, 高效脱硫, 除尘, 关键技术

Abstract: In order to systematically study the technologies of high efficiency desulfurization and collaborative dust removal, the actual application status of high efficiency desulfurization and collaborative dust removal in typical unit has been analyzed. It is clarified that to implement high efficiency desulfurization and collaborative dust removal technology the low-low temperature electric dust removal technology and high efficiency desulphurization technology should also be taken into account. The low-low temperature electric dust removal technology requires not only strict control on smoke temperature and ratio of ash to sulfur but also well-designed flow field, flow rate and the proper material selection to prevent the flue gas cooler from wearing and leaking. High efficiency desulfurization technology requires optimized tower spray layer and demister layer flow field, reasonable tower facilities spacing and flow rate settings as well as adequate spray coverage and appropriate nozzle and defogger configuration. The ultra-low emission of SO₂ and dust can be realized effectively by virtue of the synergistic action of low temperature electric precipitating technology and high efficiency desulphurization technology. Therefore, the low-low temperature dust removal technology in combination with efficient desulfurization synergistic dust removal technology is a more preferred technical route for dust and SO₂ ultra-low emission.

Key words: thermal power generation, low-low temperature electric dust removal, high efficiency desulfurization, dust removal, key technology

中图分类号:

X51
TM621

杜振, 魏宏鸽, 张杨, 朱跃. 高效脱硫协同除尘关键技术分析[J]. 中国电力, 2018, 51(6): 37-41.

DU Zhen, WEI Hongge, ZHANG Yang, ZHU Yue. Analysis on Key Technologies of High Efficiency Desulfurization and Collaborative Dust Removal[J]. Electric Power, 2018, 51(6): 37-41.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.201802042

https://www.electricpower.com.cn/CN/Y2018/V51/I6/37

参考文献

[1] 郑婷婷, 周月桂, 金圻烨. 燃煤电厂多种烟气污染物协同脱除超低排放分析[J]. 热力发电, 2017, 46(4):10-15.ZHENG Tingting, ZHOU Yuegui, JIN Qiye. Integrated removal and ultra-low emission of multiple pollutants for coal-fired power plants[J]. Thermal Power Heneration, 2017, 46(4):10-15.
[2] 史晓宏, 李广滨, 魏书州, 等. 350 MW燃煤机组降低烟尘排放技术的研究与实践[J]. 中国电力, 2015, 48(5):93-96.SHI Xiaohong, LI Guangbin, WEI Shuzhou, et al. Research and practice on dust emission reduction technology in 350 MW coal-fired generator unit[J]. Electric Power, 2015, 48(5):93-96.
[3] 魏宏鸽, 叶伟平, 柴磊, 等. 湿法脱硫系统除尘效果分析与提效措施[J]. 中国电力, 2015, 48(8):33-36.WEI Hongge, YE Weiping, CHAI Lei, et al. Analysis of dust removal effect in wet-FGD system and its efficiency-enhancement techniques[J]. Electric Power, 2015, 48(8):33-36.
[4] 杜振, 王玉敬, 魏宏鸽, 等. 适用于燃煤机组烟尘超低排放技术路线分析[J]. 能源工程, 2017, (3):61-65.DU Zhen, WANG Yujing, WEI Hongge, et al. Analysis of suitable technical route for ultra-low emissions of soot in coal-fired units[J]. Energy Engineering, 2017, 3:61-65.
[5] 郦建国, 郦祝海, 李卫东, 等. 燃煤电厂烟气协同治理技术路线研究[J]. 中国环保产业. 2015(5):52-56.LI Jianguo, LI Zhuhai, LI Weidong, et al. Research on flue gas co-benefit control technical route in coal-fired power plants[J]. China Environmental Protection Industry. 2015(5):52-56.
[6] 姚明宇, 聂剑平, 张立欣, 等. 燃煤电站锅炉烟气污染物一体化协同治理技术[J]. 热力发电, 2016, 45(3):8-12.YAO Mingyu, NIE Jianping, ZHANG Lixin, et al. Integrative flue-gas pollutants removal technology for coal-fired utility boilers[J]. Thermal Power Generation, 2016, 45(03):8-12.
[7] 郦建国, 何毓忠, 刘含笑, 等. 低低温电除尘技术特点及在高灰煤超低排放工程中的应用[J]. 中国电力,2017,50(3):28-33.LI Jianguo, HE Yuzhong, LIU Hanxiao, et al. Low-low temperature ESP and the application in high-ash coal engineering for ultra-low emission[J]. Electric Power, 2017, 50(3):28-33.
[8] 赵海宝, 郦建国, 何毓忠, 等. 低低温电除尘关键技术研究与应用[J]. 中国电力, 2014, 47(10):117-121.ZHAO Haibao, LI Jianguo, HE Yuzhong, et al. Research and application on low-low temperature electrostatic precipitator technology[J]. Electric Power, 2014, 47(10):117-121.
[9] 王珲, 宋蔷, 姚强, 等. 电厂湿法脱硫系统对烟气中细颗粒物脱除作用的试验研究[J]. 中国电机工程学报, 2008, 28(5):1-7.WANG Hui, SONG Qiang, YAO Qiang, et al. Experimental study on removal effect tof wet flue gas desulfurization system on fine particles from a coal-fired power plant[J]. Proceedings of the CSEE, 2008, 28(5):1-7.
[10] 陆军, 刘永强, 周飞, 等. 高硫煤机组低低温省煤器SO₃协同脱除试验研究[J]. 热力发电, 2016, 45(12):30-36.LU Jun, LIU Yongqiang, ZHOU Fei, et al. Experimental research on simultaneous removal of SO₃ by low-low temperature economizer in units firing high-sulfur coal[J]. Thermal Power Generation, 2016, 45(12):30-36.
[11] 严金英, 郑重, 于国峰, 等. 燃煤烟气多污染物一体化控制技术研究进展[J]. 热力发电, 2011, 40(11):9-13.YAN Jinying, ZHENG Zhong, YU Guofeng, et al. Progress in study on multi-pollutant control technology for coal-fired flue gas[J]. Thermal Power Generation, 2011, 40(11):9-13.
[12] 宦宣州, 何育东, 王少亮, 等.湿法脱硫吸收塔协同除尘试验[J]. 热力发电, 2017, 46(7):97-102.HUAN Xuanzhou, HE Yudong, WANG Shaoliang, et al.Experiments about synergistic dust removal by WFGD system[J]. Thermal Power Generation, 2017, 46(7):97-102.
[13] 陈牧, 胡玉清, 桂本. 利用协同治理技术实现燃煤电厂烟尘超低排放[J]. 中国电力, 2015, 48(9):146-151.CHEN Mu, HU Yuqing, GUI Ben. Synergistic control technology for ultra-low PM emission from coal-fired power plants and its application[J]. Electric Power, 2015, 48(9):146-151.
[14] 中国环境保护产业协会. 燃煤电厂烟气超低排放技术[M]. 北京:中国电力出版社, 2015.

[1]	刘东旭, 张潇元, 马青, 冯前伟, 杜振. 燃煤机组SO₃生成与控制技术路线分析[J]. 中国电力, 2024, 57(6): 235-242.
[2]	张兴平, 王腾, 张馨月, 张浩楠. 基于多智能体深度确定策略梯度算法的火力发电商竞价策略[J]. 中国电力, 2024, 57(11): 161-172.
[3]	刘毅. 燃煤电厂烟气中SO₃排放控制中试研究[J]. 中国电力, 2022, 55(7): 201-208.
[4]	刘含笑, 吴黎明, 赵琳, 于立元, 郦建国, 崔盈. 燃煤电厂湿式电除尘器减排及能效特性研究[J]. 中国电力, 2022, 55(5): 196-203.
[5]	孙尊强, 郑成航, 周灿, 王圣, 马修元, 叶毅科. 燃煤电厂典型除尘器运行现状分析及优化[J]. 中国电力, 2022, 55(11): 194-201.
[6]	熊轲, 张锐晨, 王蕊, 钟桂东, 张煜. 5G助力电力物联网：网络架构与关键技术[J]. 中国电力, 2021, 54(3): 99-108.
[7]	刘玺璞, 李东阳, 张超. 多种负荷工况下湿式电除尘器的PM_2.5脱除效率及排放特征[J]. 中国电力, 2021, 54(1): 182-187.
[8]	赵宏, 张发捷, 马云龙, 马宝林, 唐潇, 徐仁博, 罗通达, 李成宝, 任传明, 于洁, 孙路石. 燃煤电厂SCR脱硝氨逃逸迁移规律试验研究[J]. 中国电力, 2021, 54(1): 196-202.
[9]	刘晓敏, 王乐乐, 黄见勋, 黄荣廷, 许积庄, 孔凡海, 谢建南, 李津津, 杨林军, 张发捷, 何川. 低低温除尘器和海水脱硫可凝结颗粒物有机组分排放特征研究[J]. 中国电力, 2020, 53(12): 263-269.
[10]	仝声, 刘乐, 王鹏飞. 基于多变量广义预测控制算法的两级过热汽温协调联动控制[J]. 中国电力, 2020, 53(10): 215-223.
[11]	杨明花, 张克涵. 基于高光谱图像和卷积神经网络的燃煤热值估计算法[J]. 中国电力, 2019, 52(9): 148-153.
[12]	刘玺璞, 李启永, 李东阳, 郭明, 李建光. 330 MW燃煤发电机组除尘系统节能优化[J]. 中国电力, 2019, 52(5): 164-169,175.
[13]	陈奎续. 电袋复合除尘器协同脱除SO₃和Hg[J]. 中国电力, 2019, 52(3): 29-35.
[14]	张志中, 张杨, 杜振, 裴煜坤, 徐克涛, 朱跃. 600 MW燃煤机组SO₂、烟尘综合治理技术经济性分析[J]. 中国电力, 2019, 52(3): 36-42.
[15]	罗如生, 朱法华, 陈奎续, 娄彤, 尤燕青. 清洁煤电技术与标准体系在“一带一路”沿线国家的应用[J]. 中国电力, 2019, 52(10): 132-137.

高效脱硫协同除尘关键技术分析

Analysis on Key Technologies of High Efficiency Desulfurization and Collaborative Dust Removal

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

模态框（Modal）标题

高效脱硫协同除尘关键技术分析

Analysis on Key Technologies of High Efficiency Desulfurization and Collaborative Dust Removal

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics