660 MW超超临界机组循环水泵配置及运行方式优化

doi:10.11930/j.issn.1004-9649.201905133

中国电力 ›› 2020, Vol. 53 ›› Issue (2): 112-119.DOI: 10.11930/j.issn.1004-9649.201905133

660 MW超超临界机组循环水泵配置及运行方式优化

王渡, 刘玉贤, 万明元, 赵思维, 江剑明

上海电力大学, 上海 200090

收稿日期:2019-05-20 修回日期:2019-12-20 出版日期:2020-02-05 发布日期:2020-02-05
作者简介:王渡(1980-),男,副教授,从事热力系统优化、大型电站运行优化及热力系统经济性分析,E-mail:wangdu2003@sina.com;刘玉贤(1995-),男,硕士研究生,从事热力系统优化、大型电站运行优化及热力系统经济性分析,E-mail:1321475630@qq.com;万明元(1992-),男,硕士,从事热力系统优化、大型电站运行优化及热力系统经济性分析,E-mail:610641819@qq.com
基金资助:
国家自然科学基金资助项目（No.51806135）。

Configuration and Operation Optimization of Circulating Water Pumps for 660 MW Ultra-supercritical Unit

WANG Du, LIU Yuxian, WAN Mingyuan, ZHAO Siwei, JIANG Jianming

Shanghai University of Electric Power, Shanghai 200090, China

Received:2019-05-20 Revised:2019-12-20 Online:2020-02-05 Published:2020-02-05
Supported by:
This work is supported by National Natural Science Foundation of China (No.51806135).

摘要/Abstract

摘要： 机组循环水泵的不同配置方案和运行方式对厂用电率存在显著影响。基于EBSILON仿真平台搭建了2×660 MW超超临界机组和4台循环水泵的仿真模型。针对机组3种不同的循环水泵配置方案，构建了不同负荷、不同循环水温度下机组的多种循环水泵组合方式。在综合考虑机组的运行费用和投资回收年限的情况下，分析了不同配置方案的技术经济性，结果显示：2台变频循环水泵为最佳配置方案，其年运行效益可增加537.677万元，估算投资回收年限1.741年。

关键词: 超超临界机组, 变频, 循环水泵, 经济性分析

Abstract: The configuration schemes and operation modes of the circulating water pump of the thermal power unit have significant impacts on the efficiency of the unit. In this paper, the simulation model of the 2×660 MW ultra supercritical unit with the four circulating water pumps are constructed by using the EBSILON platform. Then regarding three different circulating water pump configuration schemes, a variety of operation modes were established accordingly under different loads and circulating water temperatures. Considering the operation cost of the unit and the payback period of investment, different circulating water pump configuration schemes of the unit have been analyzed and compared both technically and economically. The simulation results show that the scheme configured with variable frequency speed control in two circulating water pumps is the optimal solution such that the annual operation income will increase by 5.377 million yuan and the investment payback period is expected to be about 1.741 years.

Key words: ultra supercritical power unit, variable frequency speed control, circulating water pump, economic analysis

王渡, 刘玉贤, 万明元, 赵思维, 江剑明. 660 MW超超临界机组循环水泵配置及运行方式优化[J]. 中国电力, 2020, 53(2): 112-119.

WANG Du, LIU Yuxian, WAN Mingyuan, ZHAO Siwei, JIANG Jianming. Configuration and Operation Optimization of Circulating Water Pumps for 660 MW Ultra-supercritical Unit[J]. Electric Power, 2020, 53(2): 112-119.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.201905133

https://www.electricpower.com.cn/CN/Y2020/V53/I2/112

参考文献

[1] 刘志巍. 600 MW火电机组冷端系统优化运行研究[D]. 北京:华北电力大学, 2015. LIU Zhiwei. Research on optimal operation of cold-end system for 600MW thermal power unit[D]. Beijing:North China Electric Power University, 2015.
[2] 李志恒, 张娟, 宋星. 循环水泵节能降耗的途径与实践[J]. 中国电力, 2016, 49(11):181-184 LI Zhiheng, ZHANG Juan, SONG Xing. Approach of energy saving and consumption reduction of circulating water pump and its application[J]. Electric Power, 2016, 49(11):181-184
[3] 曾峰, 程东涛, 任丽君, 等. 某1000 MW汽轮机循环水泵运行优化研究[J]. 电站系统工程, 2017, 33(5):49-51 ZENG Feng, CHENG Dongtao, REN Lijun, et al. Study on optimization of circulating water pump operation of 1000 MW steam turbine[J]. Power System Engineering, 2017, 33(5):49-51
[4] 王攀, 王泳涛, 王宝玉. 汽轮机冷端优化运行和最佳背压的研究与应用[J]. 汽轮机技术, 2016, 58(1):55-57, 60 WANG Pan, WANG Yongtao, WANG Baoyu. Optimization operation of steam turbine cold end and the best back pressure research and application[J]. Turbine Technology, 2016, 58(1):55-57, 60
[5] 林轶, 陈文和, 马汀山. 考虑清洁系数的循环泵变频优化运行分析[J]. 汽轮机技术, 2014, 56(4):299-302 LIN Yi, CHEN Wenhe, MA Tingshan. Variable frequency operation optimization analysis of circulating pump considering clean coefficient[J]. Turbine Technology, 2014, 56(4):299-302
[6] ZHOU L Y, XU G, ZHAO S F, et al. Parametric analysis and process optimization of steam cycle in double reheat ultra-supercritical power plants[J]. Applied Thermal Engineering, 2016, 99(6):652-660.
[7] 王渡, 万明元, 江剑明, 等. 基于0号高加的超临界机组热经济性的研究[J]. 汽轮机技术, 2018, 60(1):69-72, 77 WANG Du, WAN Mingyuan, JIANG Jianming, et al. Study on thermal economy of supercritical units based on the 0 high pressure heater[J]. Turbine Technology, 2018, 60(1):69-72, 77
[8] 刘学亮, 陈胜利, 万超, 等. 间接空冷汽轮机组变工况特性研究[J]. 中国电力, 2018, 51(4):108-114 LIU Xueliang, CHEN Shengli, WAN Chao, et al. Study on off-design performance of indirect air-cooling steam turbine unit[J]. Electric Power, 2018, 51(4):108-114
[9] 付亦葳, 谢天, 屈杰. 一次、二次再热机组汽轮机高低位布置方案热经济性分析[J]. 热力发电, 2017, 46(7):1-4 FU Yiwei, XIE Tian, QU Jie. Thermal-economic analysis for scheme of steam turbine generator placement in high and low platform separately[J]. Thermal Power Generation, 2017, 46(7):1-4
[10] 常东锋, 付亦葳, 王伟, 等. 1000 MW机组增设零号高压加热器经济性分析及运行优化[J]. 热力发电, 2018, 47(12):17-21 CHANG Dongfeng, FU Yiwei, WANG Wei, et al. Economic analysis and operational optimization of adding extra high pressure heater for a 1000 MW unit[J]. Thermal Power Generation, 2018, 47(12):17-21
[11] 王渡, 赵思维, 万明元, 等. 基于EBSILON的AP1000核电机组低加疏水系统研究[J]. 汽轮机技术, 2018, 60(6):427-430,434 WANG Du, ZHAO Siwei, WAN Mingyuan, et al. Study on the LP hearet drain system of AP1000 nuclear power unit based on EBSILON[J]. Turbine Technology, 2018, 60(6):427-430,434
[12] 李大才. 潮汐变化下1000 MW海水直冷机组循环水泵运行优化研究[J]. 中国电力, 2015, 48(5):103-108,132 LI Dacai. Operation optimization of circulating pump in 1000-MW direct seawater cooling generating unit under tidal variations[J]. Electric Power, 2015, 48(5):103-108,132
[13] 赵宏伟, 董玉亮, 耿直. 600 MW双压凝汽器最佳真空计算的改进及运行优化[J]. 汽轮机技术, 2015, 57(6):447-450 ZHAO Hongwei, DONG Yuliang, GENG Zhi. The improvement of double pressure condenser optimum vacuum and operation optimization for 600 MW power units[J]. Turbine Technology, 2015, 57(6):447-450
[14] 汪飞, 刘晓鸿, 万忠海, 等. 超超临界汽轮机循环水系统改造及运行优化[J]. 中国电力, 2015, 48(3):1-5 WANG Fei, LIU Xiaohong, WAN Zhonghai, et al. Optimization of cooling water circulation system modification and operation for ultra-supercritical steam turbine units[J]. Electric Power, 2015, 48(3):1-5
[15] 徐正, 张明, 周猛, 等. 供热机组冷端优化配置研究[J]. 黑龙江电力, 2018, 40(4):342-347, 352 XU Zheng, ZHANG Ming, ZHOU Meng, et al. The research on the cold end optimization configuration for heat and power generation[J]. Heilongjiang Electric Power, 2018, 40(4):342-347, 352
[16] 汪力. 集中供热网循环水泵采用变频调速的分析与计算[J]. 中国新技术新产品, 2018(6):45-46
[17] 李志龙, 李艳超, 于海东, 等. 1000 MW火电机组凝结水泵变频改造分析[J]. 热能动力工程, 2015, 30(5):145-149 LI Zhilong, LI Yanchao, YU Haidong, et al. Analysis of the variable frequency modification to the condensate water pump of a 1000 MW unit in a thermal power plant[J]. Journal of Engineering for Thermal Energy and Power, 2015, 30(5):145-149

660 MW超超临界机组循环水泵配置及运行方式优化

Configuration and Operation Optimization of Circulating Water Pumps for 660 MW Ultra-supercritical Unit

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	刘钟淇, 刘耀, 侯金鸣. 以深远海风电为核心的能源岛能源外送经济性分析[J]. 中国电力, 2024, 57(9): 94-102.
[2]	黄伟捷, 江岳文. 远海风电输电和制氢经济可行性分析[J]. 中国电力, 2022, 55(1): 91-100.
[3]	卢嘉豪, 洪锐媛, 陈思哲. 可变频率变压器的最大功率传输控制策略[J]. 中国电力, 2021, 54(12): 20-28.
[4]	卢嘉豪, 陈思哲. 双边不对称工况下无网侧变换器型可变频率变压器的控制策略[J]. 中国电力, 2021, 54(12): 29-37.
[5]	杨晖, 段立强, 王振, 刘玉磊. 槽塔结合太阳能辅助燃煤发电机组性能分析[J]. 中国电力, 2019, 52(7): 99-107.
[6]	张金营, 孙蓟光. 基于控制受限MIMO预测控制的超超临界机组集中式协调控制[J]. 中国电力, 2019, 52(5): 21-28.
[7]	梁秀进, 朱文韬, 魏宏鸽, 朱跃. 燃煤机组烟气消白技术路线选择与经济分析[J]. 中国电力, 2019, 52(3): 16-22.
[8]	黄郑, 殳建军, 于国强, 司风琪, 周建新. 燃气-蒸汽联合循环机组循环水泵优化管理系统设计与开发[J]. 中国电力, 2019, 52(3): 120-126.
[9]	张楚, 杨毅, 金格, 刘石, 高庆水. 循环水泵动态镜板翘曲故障诊断及振动评价讨论[J]. 中国电力, 2019, 52(2): 144-148,177.
[10]	娄奇鹤, 谢国辉, 李娜娜. 平价上网时代新能源发电经济性分析和发展趋势[J]. 中国电力, 2019, 52(12): 1-9,104.
[11]	王亚欧, 陶谦, 肖杰, 陈波. 1 000 MW双切圆燃烧锅炉干湿态转换过程中水冷壁温度控制[J]. 中国电力, 2019, 52(1): 161-165,173.
[12]	牟春华, 吕凯, 许朋江, 孙大伟, 兀鹏越, 马汀山, 居文平, 李冬泉. 辅机统调动力源系统在某660 MW机组的应用[J]. 中国电力, 2018, 51(9): 65-72.
[13]	俞葆青, 彭杏娜, 丛相州, 彭先宽, 杜占江, 高志. 超超临界机组疏水罐罐体泄漏原因分析及防治[J]. 中国电力, 2018, 51(9): 83-87,150.
[14]	孟海洋. 新型国产1 050 MW超超临界机组高压主汽阀卡涩原因分析及改进[J]. 中国电力, 2018, 51(7): 90-94.
[15]	牟春华, 程东涛, 居文平, 马汀山. 大型汽轮机循环水泵改造选型问题分析[J]. 中国电力, 2018, 51(5): 106-110.

模态框（Modal）标题

660 MW超超临界机组循环水泵配置及运行方式优化

Configuration and Operation Optimization of Circulating Water Pumps for 660 MW Ultra-supercritical Unit

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics