间接空冷汽轮机组变工况特性研究

doi:10.11930/j.issn.1004-9649.201711151

摘要/Abstract

摘要： 以某600MW间接空冷汽轮机组为例，利用EBSILON软件建立了汽轮机和凝汽器模型，结合空冷塔模型完成三者耦合计算，通过正交试验方法研究了多种变工况特性，获得了不同环境温度、循环水流量和机组负荷下背压和热耗率的变化规律。结果表明：机组在相同负荷和循环水流量下，随着环境温度上升，背压和热耗率不断升高，在高温段上升速率明显快于低温段；机组负荷一定，在同样的循环水流量变化幅度下，环境温度越高，背压和热耗率的变化速率越大；在一定环境温度和循环水流量下，随着负荷增大，背压升高，热耗率下降；在机组负荷和循环水流量不变时，空冷塔出口水温上升速率大于环境温度上升速率，在100%循环水流量下，前者为后者的1.11~1.15倍，导致凝汽器进口水温迅速升高，机组运行经济性下降。

关键词: 间接空冷系统, 汽轮机组, 变工况, 背压, 热耗率, EBSILON

Abstract: Taking a 600-MW indirect air-cooling steam turbine unit for example, the calculation model of steam turbine, condenser and air-cooling tower is established on the basis of EBSILON software. Characteristics regarding to a variety of operation conditions are studied through the orthogonal test method, such that the variations of back pressure with respect to heat rate under the conditions of different ambient temperatures, circulating water flows and steam turbine loadings are obtained. The results show that, with constant circulating water flow and steam turbine load, as the ambient temperature goes up, the back pressure and the heat rate will keep rising. In particular the increasing rate in the high-temperature section is apparently higher than that in the low-temperature section. If the steam turbine load remains constant, the higher the ambient temperature, the higher the changing rate of the back pressure and the heat consumption rate under the same cyclic water flow. In the case of constant ambient temperature and the circulating water flow, with the raise of steam turbine load, the back pressure will increase while the heat rate will drop down. In the case of constant steam turbine load and circulating water flow, the rising rate of the outlet water temperature for the air-cooling tower is greater than that of the ambient temperature rise. Specifically, the former will be 1.11-1.15 times of the latter if the circulating water flow reaches full volume limit, which will lead to the rapid increase of the inlet water temperature at the condenser and the decline of the system economy performance.

Key words: indirect air-cooling system, steam turbine unit, off-design, back pressure, heat rate, EBSILON software

中图分类号:

TK264

刘学亮, 陈胜利, 万超, 李高潮. 间接空冷汽轮机组变工况特性研究[J]. 中国电力, 2018, 51(4): 108-114.

LIU Xueliang, CHEN Shengli, WAN Chao, LI Gaochao. Study on Off-Design Performance of Indirect Air-Cooling Steam Turbine Unit[J]. Electric Power, 2018, 51(4): 108-114.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.201711151

https://www.electricpower.com.cn/CN/Y2018/V51/I4/108

参考文献

[1] 李峰. 海勒式间接空冷塔性能研究与改造[D]. 北京: 华北电力大学能源动力与机械工程学院,2006.LI Feng. Research and alteration of Heller-type indirect air-cooling tower [D]. Beijing: North China Electric Power University, 2006.
[2] 金生祥, 王清. 空冷机组混合冷却的综合应用及发展前景[J]. 中国电力, 2013, 46(6): 5-9.JING Shengxiang, WANG Qing. Comprehensive application and prospect of hybrid cooling for air-cooled units [J]. China Power, 2013, 46(6): 5-9.
[3] 刘培忠, 杨志军. 高寒地区间接空冷机组散热器防冻预暖措施[J]. 中国电力. 2013, 46(5): 18-22.LIU Peizhong, YANG Zhijun. Anti-freezing and pre-heating measures for radiator in indirect air-cooling units in cold areas [J]. China Power, 2013, 46(5): 18-22.
[4] 张春雨, 严俊杰, 李秀云, 等. 哈蒙式间接空冷系统变工况特性的理论研究[J]. 动力工程, 2000, 20(1): 566-570.ZHANG Chunyu, YAN Junjie, Li Xiuyun, et al. Theoretical research on part load operation performance of Hamen indirect air-cooled system [J]. Journal of Power Engineering, 2000, 20(1): 566-570.
[5] 张春雨, 严俊杰, 林万超. 海勒式间接空冷系统变工况特性理论研究[J]. 工程热物理学报, 2004, 25(1): 13-16.Zhang Chunyu, Yan Junjie, Lin Wanchao. A theoretical study on part load operation performance of Hailler indirect air-cooled system [J]. Journal of Engineering Thermophysics, 2004, 25(1): 13-16.
[6] 赵波, 杨善让, 张辉, 等. 复合制冷循环间接空冷系统变工况特性分析[J]. 中国电机工程学报, 2014, 34(20): 3308-3316.ZHAO Bo, YANG Shanrang, ZHANG Hui, et al. Performance analysis of off-design operation features for indirect air cooled system with compound refrigeration cycle [J]. Proceedings of the CSEE, 2014, 34(20): 3308-3316.
[7] 郝满晋, 涂光备, 陈冠益, 等. 海勒式空冷系统接入附加冷却变况分析[J]. 工程热物理学报, 2008, 29(10): 1636-1640.HAO Manjin, XU Guangbei, CHEN Guanyi, et al. Analysis part load operation performance of Hailer indirect air-cooled system with adjunctive cooled system [J]. Journal of Engineering Thermophysics, 2008, 29(10): 1636-1640.
[8] 孔令华. 空冷机组冷端系统运行特性分析及优化[D]. 北京: 华北电力大学能源动力与机械工程学院, 2008.KONG Linghua. Study on the operational performance’s analysis and optimizing of air-cooling cold-end system in power plant unit [D]. Beijing: North China Electric Power University, 2008.
[9] 薛海君, 王永新, 石磊. 间接空冷系统冷端优化设计软件研发[J]. 华电技术, 2016, 38(7): 11-15.XUE Haijun, WANG Yongxin, SHI Lei. Research and development on opti-mization of design software on the cooling side of indirect dry cooling system [J]. Huadian Technology, 2016, 38(7): 11-15.
[10] Yang L J, Wu X P, Du X Z, et al. Dimensional characteristics of wind effects on the performance of indirect dry cooling system with vertically arranged heat exchanger bundles [J]. International Journal of Heat and Mass Transfer, 2013, 67: 853-866.
[11] KAPAS N. Behavior of natural draught cooling towers in wind [C]//CMFF. Budapest, Hungary, 2003.
[12] 孙奉仲. 冷却塔设计的数学模型及先进设计方法[J]. 山东电力技术, 2002(6): 6-9.Sun Fengzhong. The math method and advanced design method of cooling tower [J]. Shandong Dianli Jishu, 2002(6): 6-9.
[13] 杨立军, 贾思宁, 卜永东, 等. 电站间冷系统空冷散热器翅片管束流动传热性能的数值研究[J]. 中国电机工程学报, 2012, 32(32): 50-58.YANG Lijun, JIA Sining, BU Yongdong. Et al. Numerical study onflow and heat transfer characteristics of finned tube bundles for air-cooled heat exchangers of indirect dry cooling systems in power plants [J]. Proceedings of the CSEE, 2012, 32(32): 50-58.
[14] 张凯峰, 杨立军, 杜小泽, 等. 空冷凝汽器波形翅片扁平管管束外空气流动传热特性[J]. 中国电机工程学报, 2008, 28(26): 24-28.Zhang Kaifeng, Yang Lijun, Du Xiaoze, et al. Flow and heat transfer characteristics of cooling air outside the flat wave-finned tube banks of air-cooled condensers [J]. Proceedings of the CSEE, 2008, 28(26): 24-28.
[15] 杨立军, 张凯峰, 杜小泽, 等. 空冷凝汽器椭圆翅片椭圆管束外空气的流动与传热特性[J]. 动力工程, 2008, 28(6): 911-914.Yang Lijun, Zhang Kaifeng, Du Xiaoze, et al. Flow and heat transfer characteristics of cooling air outside elliptical tube bundles fixed with elliptical fin in air-cooled condenser [J]. Journal of Power Engineering, 2008, 28(6): 911-914.
[16] 马欢, 司风琪, 李岚, 等. 间接空冷系统变工况快速计算模型[J]. 东南大学学报(自然科学版), 2015, 45(1): 79-84.MA Huan, SI Fengqi, LI Lan, et al. Numerical research and analysis on operation performance of indirect air-cooled units in different conditions [J]. Journal of Southeast University (Natural Science Edition), 2015, 45(1): 79-84.
[17] 卜永东, 杨立军, 杜小泽, 等. 电站空冷系统变工况性能的数值研究[J]. 中国电机工程学报, 2012, 32(35): 66-73.BU Yongdong, YANG Lijun, DU Xiaoze, et al. A numerical approach to off-design performance of dry cooling systems in power plants [J]. Proceedings of the CSEE, 2012, 32(35): 66-73.
[18] 李岚. 大型间接空冷系统运行特性分析与优化[D]. 南京: 东南大学能源与环境工程学院, 2015.LI Lan. Thermo-flow performance analysis and optimization of large-scale indirect air-cooling system [D]. Nanjing: Southeast University, 2015.
[19] 付亦葳, 马汀山, 刘永林. 基于EBSILON的蒸汽冷却器节能效果评估[J]. 热力发电, 2017, 46(3): 14-18.FU Yiwei, MA Tingshan, LIU Yonglin. An EBSILON-based evaluation method for energy saving of steam cooler [J]. Thermal Power Generation, 2017, 46(3): 14-18.
[20] 李辉. 基于在线支持向量回归算法的电站热耗率模型[J]. 中国电力, 2014, 47(7): 21-25.LI Hui. The turbine heat rate model based on accurate online support vector regression algorithm [J]. Electric Power, 2014, 47(7):21-25.
[21] 杨立军, 杜小泽, 杨勇平. 空冷凝汽器全工况运行特性分析[J]. 中国电机工程学报, 2008, 28(8): 24-28.YANG Lijun, DU Xiaoze, YANG Yongping. Performance analysis of air-cooled condensers at all operating conditions[J]. Proceedings of the CSEE, 2008, 28(8): 24-28.