Technical Study and Demonstration Project on the Quality Control and Drying of Terminal Wastewater in Coal-Fired Power Plants

doi:10.11930/j.issn.1004-9649.201802100

Abstract

Abstract: In compliance with the requirement for zero wastewater discharge in coal-fired power plants, the quality control technology and drying technology of the terminal wastewater are studied and discussed in this paper in order to properly dispose the terminal wastewater based on the analysis of the wastewater quality and the existing wastewater zero discharge treatment technology. The drying process and its influencing factors of saline drip are researched. After the comparison of atomization and flue gas distribution, the technology of treating terminal wastewater by flue gas bypass drying is finally determined to be applied, and then corresponding engineering application is carried out, which is the first project demonstration project completed in China. Moreover, the engineering effect and operation economy are evaluated.

Key words: coal-fired power plants, terminal effluent, by-pass fule gas drying, demonstration project

CLC Number:

TM628

YAO Zilin, YUAN Weizhong, CHEN Biao, LIU Chunhong, TONG Xiaozhong. Technical Study and Demonstration Project on the Quality Control and Drying of Terminal Wastewater in Coal-Fired Power Plants[J]. Electric Power, 2018, 51(6): 48-53.

Add to citation manager EndNote|Ris|BibTeX

URL: https://www.electricpower.com.cn/EN/10.11930/j.issn.1004-9649.201802100

https://www.electricpower.com.cn/EN/Y2018/V51/I6/48

References

[1] 樊惠生, 王艺蓉. 燃煤电厂超低排放改造需注意的若干问题[J]. 中国电力企业管理, 2016(7):76-77.
[2] 杨宝红, 汪德良, 王正江. 火力发电厂废水处理与回用[M]. 北京:化学工业出版社, 2006.
[3] 李兵, 张其龙, 王学同, 等. 燃煤电厂废水零排放处理技术[J]. 水处理技术, 2017, 43(6):24-28.LI Bing, ZHANG Qilong, WANG Xuetong, et al. Research progress of technologies for zero-discharge of desulfurization wastewater from coal-fired power plants[J]. Technology of Water Treatment, 2017, 43(6):24-28.
[4] CHU P. Technical manual:guidance for assessing wastewater impacts of FGD scrubbers, EPRI Report 1013313[R]. Palo Alto, CA:Electric Power Research Institute, 2006.
[5] 吴怡卫. 石灰石-石膏湿法烟气脱硫废水处理的研究[J]. 中国电力, 2006, 39(4):75-78.WU Yiwei. Study on the wastewater treatment in limestone-gypsum wet FGD process[J]. Electric Power, 2006, 39(4):75-78.
[6] 李慧. 火电厂再生废水反渗透回收工艺研究[D]. 西安:长安大学, 2015.
[7] 晋银佳, 孙海峰, 王丰吉, 等. 燃煤电厂高盐废水"零排放"处理工艺及技术经济分析[J]. 华电技术, 2017, 39(12):46-49.JIN Yinjia, SUN Haifeng, WANG Fengji, et al. Technical and economic analysis of "zero emission" treatment of high salinity wastewater from coal-fired power plants[J]. Huadian Technology, 2017, 39(12):46-49.
[8] USEPA. Technical development document for the proposed effluent limitations guidelines and standards for the steam electric power generating point source, EPA-821-R-13-00[R]. US:USEPA, 2013.
[9] HOQUE S, ALEXANDER T, GURIAN P L. Innovative technologies increase evaporation pond efficiency[J]. IDA Journal of Desalination and Water Reuse, 2010, 2(1):72-78.
[10] 雷云, 解庆林, 李艳红. 高盐度废水处理研究进展[J]. 环境科学与管理, 2007, 32(6):94-98.LEI Yun, XIE Qinglin, LI Yanhong. The study on the treatment of high salinity waste water[j]. Environmental Science and Management, 2007, 32(6):94-98.
[11] 黄立新, 王宗濂, 唐金鑫. 我国喷雾干燥技术研究及进展[J]. 化学工程, 2001, 29(2):51-55.HUANG Lixin, WANG Zonglian, TANG Jinxin. Development of a new centrifugal pneumatic classifier for powder materials[J]. Chemical Engineering(China), 2001, 29(2):51-55.
[12] 张登平, 郭举. 压力式雾化器特性的研究[J]. 云南化工, 2008, 35(6):39-41.ZHANG Dengping, GUO Ju. Properties of pressured atomizer[J]. Yunnan Chemical Technology, 2008, 35(6):39-41.
[13] 刘桂华. 小型气流雾化器[J]. 沈阳化工, 1986(1):18-21.
[14] 丁又青, 李翔, 杨大军, 等. 用于烟气净化处理的高速离心式雾化器雾化盘:CN202590999U[P]. 2012.
[15] Э. П. ДРЕЙШНЕР, 潘福林. 离心式喷嘴雾化器的计算与分析[J]. 石油化工设备, 1985(4):56-57.
[16] 刘殿宇. 热风分配器的改进[J]. 化工设计, 1998(3):33-34.LIU Dianyu. Improvement of hot air distriutor[J]. Chemical Engineering Design, 1998(3):33-34.
[17] 马双忱, 于伟静, 贾绍广, 等. 燃煤电厂脱硫废水处理技术研究与应用进展[J]. 化工进展, 2016, 35(1):255-262.MA Shuangchen, YU Weijing, JIA Shaoguang, et al. Research and application progresses of flue gas desulfurization (FGD) wastewater treatment technologies in coal-fired plants[J]. Chemical Industry and Engineering Progress, 2016, 35(1):255-262.
[18] GETLER J L, SHELTON H L, FURLONG D A. Modeling the spray absorption process for SO₂ removal[J]. Journal of the Air Pollution Control Association, 1979, 29(12):1270-1274.
[19] HILL F F, ZANK J. Flue gas desulphurization by spray dry absorption[J]. Chemical Engineering and Processing:Process Intensification. 2000, 39(1):45-52.
[20] 刘广文. 喷雾干燥实用技术大全[M]. 北京:中国轻工业出版社, 2001.
[21] 袁伟中, 刘春红, 童小忠, 等. 燃煤锅炉采用烟气旁路干燥技术实现脱硫废水零排放[J]. 电力科技与环保, 2017, 33(3):18-21.YUAN Weizhong, LIU Chunhong, TONG Xiaozhong, et al. Coal - fired boiler flue gas bypass drying technology to achieve zero liquid discharge of desulfurization water[J]. Electric Power Technology and Environmental Protection, 2017, 33(3):18-21.