低负荷吹灰对超临界锅炉水冷壁超温影响的试验研究

doi:10.11930/j.issn.1004-9649.202003111

中国电力 ›› 2020, Vol. 53 ›› Issue (11): 227-233.DOI: 10.11930/j.issn.1004-9649.202003111

低负荷吹灰对超临界锅炉水冷壁超温影响的试验研究

王洋¹, 朱晓昕¹, 陈铭², 汪华剑¹, 房凡¹, 朱伟建¹

1. 西安热工研究院有限公司，陕西西安 710054;
2. 深能合和电力（河源）有限公司，广东河源 517000

收稿日期:2020-03-17 修回日期:2020-05-07 出版日期:2020-11-05 发布日期:2020-11-05
通讯作者: 陕西省技术创新引导专项(基金)资助项目(2018HJCG-15)
作者简介:王洋(1988—)，男，硕士，工程师，从事电站锅炉相关技术研究及应用工作，E-mail：angus081428@163.com
基金资助:
This work is supported by Technology Innovation Leading Program of Shaanxi (No.2018HJCG-15)

Experimental Studies on the Influence of Soot Blowing on the Overheating of Water Wall Pipes under Low Loads in Supercritical Boilers

WANG Yang¹, ZHU Xiaoxin¹, CHEN Ming², WANG Huajian¹, FANG Fan¹, ZHU Weijian¹

1. Xi'an Thermal Power Research Institute Co., Ltd., Xi'an 710054, China;
2. Shenzhen Energy Hopewell Power (Heyuan) Co., Ltd., Heyuan 517000, China

Received:2020-03-17 Revised:2020-05-07 Online:2020-11-05 Published:2020-11-05

摘要/Abstract

摘要： 通过对低负荷段吹灰器投运位置、频次、负荷段及对应区域配风方式的试验研究，发现低负荷段吹灰器投运时明显的壁温突升主要发生在两侧墙，且投运燃尽风上下位置的吹灰器影响较大，最高壁温突升幅度约100~130 ℃。吹灰过程中增大对应区域的辅助风门开度约20%，壁温突升幅度可降低约20 ℃，同时，选择较高负荷段投运吹灰器以及降低吹灰器的投用频次对控制水冷壁超温有利。试验研究方法与结论对同类型机组低负荷段吹灰器投运具有一定的参考意义。

关键词: 超临界锅炉, 吹灰, 水冷壁, 超温, 低负荷

Abstract: In this paper, through the experimental studies on the installation location, operation frequency, time period of load section and corresponding wind distribution mode of the soot blowers under low loads, it is observed that the sudden rise of wall temperature mainly occurs on the two side walls during soot blowing under low loads, and particularly the ash blowers above and under the overfire air port have substantial effects with the maximum temperature surge amplitude of about 100~130 ℃. In the process of ash blowing, with the auxiliary air volume increased by about 20% in the corresponding area, the temperature surge amplitude can be reduced by about 20 ℃. At the same time, choosing the time section of higher load for soot blowing and reducing the operation frequency of the soot-blowers are also helpful for the control of the water wall overheating. The experimental research method and conclusions have appeared to have certain referential significance to the soot-blower operation of units with the same type under low load conditions.

Key words: supercritical boiler, soot blowing, water wall, overtemperature, low load

王洋, 朱晓昕, 陈铭, 汪华剑, 房凡, 朱伟建. 低负荷吹灰对超临界锅炉水冷壁超温影响的试验研究[J]. 中国电力, 2020, 53(11): 227-233.

WANG Yang, ZHU Xiaoxin, CHEN Ming, WANG Huajian, FANG Fan, ZHU Weijian. Experimental Studies on the Influence of Soot Blowing on the Overheating of Water Wall Pipes under Low Loads in Supercritical Boilers[J]. Electric Power, 2020, 53(11): 227-233.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.202003111

https://www.electricpower.com.cn/CN/Y2020/V53/I11/227

参考文献

[1] 陈有福, 徐颂梅, 管诗骈, 等. 炉膛火焰中心位置与下水冷壁出口壁温关系研究[J]. 热力发电, 2018, 47(6): 71-77
CHEN Youfu, XU Songmei, GUAN Shipian, et al. Study on the relationship between the central position of furnace flame and the temperature of water wall outlet[J]. Thermal Power Generation, 2018, 47(6): 71-77
[2] 张志正, 孙保民, 郭永红, 等. 超(超)临界压力锅炉膜式水冷壁危险点壁温在线监测方法研究[J]. 中国电机工程学报, 2005, 25(3): 130-134
ZHANG Zhizheng, SUN Baomin, GUO Yonghong, et al. Research on on-line temperature monitoring of severe point on membrane water wall of ultra-supercritical boiler.[J]. Proceedings of the CSEE, 2005, 25(3): 130-134
[3] 王为术, 徐维晖, 李帅帅, 等. 1 000 MW超超临界锅炉高热负荷区垂直水冷壁温度特性研究[J]. 电站系统工程, 2011, 27(6): 9-12
WANG Weishu, XU Weihui, LI Shuaishuai, et al. Temperature study on vertical membrane water-wall of 1 000 MW ultra-supercritical pressure boilers in high heat flux area[J]. Power System Engineering, 2011, 27(6): 9-12
[4] 毛晓飞, 左志雄, 汪正海, 等. 燃用高硫煤四角切圆锅炉水冷壁高温腐蚀治理[J]. 热力发电, 2019, 48(4): 96-103
MAO Xiaofei, ZUO Zhixiong, WANG Zhenghai, et al. High temperature corrosion control for water wall of a tangentially-fired boiler firing high sulfur coal[J]. Thermal Power Generation, 2019, 48(4): 96-103
[5] 李斌, 汪华剑, 梁学东, 等. 超超临界锅炉水冷壁管传热恶化对横向裂纹影响的有限元分析[J]. 中国电力, 2015, 48(12): 64-69
LI Bin, WANG Huajian, LIANG Xuedong, et al. FEM analysis of heat transfer crisis of water wall tube on transverse crack in ultra-supercritical pressure boiler[J]. Electric Power, 2015, 48(12): 64-69
[6] 张冰清, 田进, 张志博, 等. 火电厂锅炉水冷壁管失效原因分析[J]. 热力发电, 2019, 48(5): 97-101
ZHANG Bingqing, TIAN Jin, ZHANG Zhibo, et al. Failure analysis for boiler water wall tubes in thermal power plants[J]. Thermal Power Generation, 2019, 48(5): 97-101
[7] 汪华剑, 周虹光, 王洋, 等. 1 000 MW垂直管圈超超临界锅炉水冷壁工质相变转换对金属壁温影响的试验研究[J]. 锅炉技术, 2017, 48(6): 13-18
WANG Huajian, ZHOU Hongguang, WANG Yang, et al. Experimental study on influence of working medium phase change on metal temperature of water wall tube in a 1 000 MW ultra supercritical vertical water wall boiler[J]. Boiler Technology, 2017, 48(6): 13-18
[8] 牟春华, 居文平, 黄嘉驷, 等. 火电机组灵活性运行技术综述与展望[J]. 热力发电, 2018, 47(5): 1-7
MU Chunhua, JU Wenping, HUANG Jiasi, et al. Review and prospect of technologies of enhancing the flexibility of thermal power units[J]. Thermal Power Generation, 2018, 47(5): 1-7
[9] 李玲, 刘鑫屏. 新能源大规模并网条件下火电机组深度调峰控制策略优化[J]. 中国电力, 2020, 53(1): 155-161
LI Ling, LIU Xinping. Control strategy optimization for thermal power unit adapted to deep peak shaving for large-scale new energy source integration[J]. Electric Power, 2020, 53(1): 155-161
[10] 徐昊亮, 靳攀润, 姜继恒, 等. 促进风电消纳的发电权交易优化方法[J]. 中国电力, 2020, 53(3): 167-176
XU Haoliang, JIN Panrun, JIANG Jiheng, et al. Optimization method of generation rights transaction mechanism for power system accommodation improvement[J]. Electric Power, 2020, 53(3): 167-176
[11] 张正陵. 中国“十三五”新能源并网消纳形势、对策研究及多情景运行模拟分析[J]. 中国电力, 2018, 51(1): 2-9
ZHANG Zhengling. Research on situation and countermeasures of new energy integration in the 13th Five-Year Plan period and its multi-scenario simulation[J]. Electric Power, 2018, 51(1): 2-9
[12] 周科, 罗小鹏, 陈玉忠, 等. “W”火焰600 MW超临界直流锅炉低负荷水冷壁超温浅析及应对方式[J]. 贵州电力技术, 2013, 16(3): 17-20, 46
ZHOU Ke, LUO Xiaopeng, CHEN Yuzhong, et al. Analysis of low loads water wall overheating of W flame 600 MW supercritical DC boiler and its countermeasures[J]. Guizhou Electric Power Technology, 2013, 16(3): 17-20, 46
[13] 沈玉华. 600 MW超临界压力锅炉50%负荷时后水冷壁超温问题的探讨[J]. 中国电力, 1997, 30(3): 33-34, 61
SHEN Yuhua. Study of overtemperature problem with rear water-cooled wall of supercritical pressure 600 MW boiler at 50% of output[J]. Electric Power, 1997, 30(3): 33-34, 61
[14] 周俊波, 陈晓文, 高海东, 等. 燃煤电站锅炉受热面灰污监测与智能吹灰控制技术[J]. 热力发电, 2017, 46(12): 11-17
ZHOU Junbo, CHEN Xiaowen, GAO Haidong, et al. Fouling monitoring and intelligent sootblowing control technologies for coal-fired boilers[J]. Thermal Power Generation, 2017, 46(12): 11-17
[15] 王洋, 汪华剑, 严响林, 等. 吹灰对超超临界锅炉水冷壁超温影响的试验研究[J]. 热能动力工程, 2019, 34(10): 90-96
WANG Yang, WANG Huajian, YAN Xianglin, et al. Experimental study on the influences of soot blowing on the water wall over-temperature in ultra-supercritical boiler[J]. Journal of Engineering for Thermal Energy and Power, 2019, 34(10): 90-96
[16] 陈铭, 王永杰, 刘晓东. 超超临界直流锅炉水冷壁横向裂纹治理[J]. 热能动力工程, 2019, 34(5): 142-148
CHEN Ming, WANG Yongjie, LIU Xiaodong. Governance of transverse cracks in water wall of ultra-supercritical once-through boiler[J]. Journal of Engineering for Thermal Energy and Power, 2019, 34(5): 142-148
[17] 陈映红, 李瞳. 河源电厂水冷壁超温爆管原因分析及预防措施[J]. 科技视界, 2013(18): 136, 185
[18] 陈铭, 杨演. 吹灰器故障造成直流锅炉水冷壁超温事故的分析[J]. 科技信息, 2012(7): 594, 591
[19] 刘福国, 赵乃国, 崔福兴, 等. 基于炉膛声波测温的水冷壁灰污系数测量研究[J]. 中国电机工程学报, 2018, 38(17): 5134-5141, 5310
LIU Fuguo, ZHAO Naiguo, CUI Fuxing, et al. On-line monitoring of ash fouling in furnace waterwalls based on acoustic pyrometry[J]. Proceedings of the CSEE, 2018, 38(17): 5134-5141, 5310
[20] 杨世铭, 陶文铨. 传热学[M]. 北京: 高等教育出版社, 1998.
[21] 王洋, 汪华剑, 周虹光, 等. 超超临界锅炉水冷壁温度测试方法与应用研究[J]. 中国电力, 2019, 52(1): 166-173
WANG Yang, WANG Huajian, ZHOU Hongguang, et al. Study on testing method and application of water wall tube temperature for ultra-supercritical boiler[J]. Electric Power, 2019, 52(1): 166-173

低负荷吹灰对超临界锅炉水冷壁超温影响的试验研究

Experimental Studies on the Influence of Soot Blowing on the Overheating of Water Wall Pipes under Low Loads in Supercritical Boilers

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	王凯, 李玉刚, 刘志坦, 王波, 邵卫卫, 孙晨. 联合循环电站低负荷烟气成分控制对策研究[J]. 中国电力, 2020, 53(5): 172-178.
[2]	雷嗣远, 李海浩, 李乐田, 倪贵东, 孔凡海, 吴国勋, 卞子君. SCR脱硝低负荷投运烟气调温旁路改造设计[J]. 中国电力, 2019, 52(9): 179-184.
[3]	宋玉宝, 刘鑫辉, 何川, 王兴俊, 王乐乐, 程世军, 马云龙, 梁俊杰. SCR催化剂低负荷运行硫酸氢铵失活研究[J]. 中国电力, 2019, 52(1): 144-150.
[4]	王亚欧, 陶谦, 肖杰, 陈波. 1 000 MW双切圆燃烧锅炉干湿态转换过程中水冷壁温度控制[J]. 中国电力, 2019, 52(1): 161-165,173.
[5]	王洋, 汪华剑, 周虹光, 严响林, 白鹏, 卢琦. 超超临界锅炉水冷壁温度测试方法与应用研究[J]. 中国电力, 2019, 52(1): 166-173.
[6]	许伟刚, 谭厚章, 刘原一, 魏博, 惠世恩. 水冷壁高温腐蚀倾向判断及H₂S近壁面许用浓度研究[J]. 中国电力, 2018, 51(7): 113-119.
[7]	章良利, 李敏, 周晓蒙, 郦宜进, 杨建国, 赵虹, 施浩勋. 深度调峰下燃煤机组运行方式对能耗的影响[J]. 中国电力, 2017, 50(7): 85-.
[8]	刘昕昶, 鄢晓忠, 敬佩, 李佩, 张艺漫, 吴爱军, 陈绍龙. 660 MW超临界对冲火焰锅炉水冷壁高温腐蚀原因探究[J]. 中国电力, 2017, 50(5): 7-12.
[9]	邓山, 李健平, 吕海涛, 张建忠, 吴利平. 火电机组低负荷下主要节能潜力探讨[J]. 中国电力, 2017, 50(3): 83-87.
[10]	闫顺林, 孙志强, 朱光明, 段学农. 300 MW锅炉卫燃带改造对燃烧影响的数值模拟[J]. 中国电力, 2017, 50(2): 82-87.
[11]	石书雨, 李志, 赵超, 张勇, 杨天亮. 超超临界二次再热锅炉热力计算系统的研发及工程应用[J]. 中国电力, 2017, 50(2): 75-81.
[12]	尤良洲, 杜振, 江建平, 朱跃. 管束式除尘除雾器在脱硫串塔系统中的应用及性能评价[J]. 中国电力, 2017, 50(12): 173-177.
[13]	苏烨，张鹏，张永军，何永君，戴航丹. 特高压受端电网燃气轮机发电机组的深度调峰研究[J]. 中国电力, 2016, 49(6): 30-34.
[14]	邓玲惠，康豫军，王军民，程勇明，王必宁. 某超临界锅炉减温管翘曲变形及开裂原因的有限元分析[J]. 中国电力, 2016, 49(5): 72-75.
[15]	郭杰，秦希超. 1 000 MW超超临界机组锅炉燃烧优化试验研究[J]. 中国电力, 2015, 48(5): 97-102.

模态框（Modal）标题

低负荷吹灰对超临界锅炉水冷壁超温影响的试验研究

Experimental Studies on the Influence of Soot Blowing on the Overheating of Water Wall Pipes under Low Loads in Supercritical Boilers

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics