大型发电机组注入式定子接地保护调试与整定

doi:10.11930/j.issn.1004-9649.2013.9.92.3

摘要/Abstract

摘要： 随着发电机单机容量的不断增大,发电机定子绕组对地电容不断增加,导致定子单相接地电流不断增大,容易造成发电机定子对地绝缘老化或出现接地故障,对发电机定子单相接地保护提出了更高的要求以确保发电机安全运行。阐述了注入式定子接地保护原理及现场调试方法,并对相角补偿值、阻抗补偿值及对相关的保护值进行了整定。根据现场对发电机静止状态下的调试以及发电机由空载缓慢升压至30%额定电压后的测试结果,进一步验证了保护定值整定的正确性和保护装置动作的准确性。

关键词: 发电机, 注入式, 定子接地保护, 调试

Abstract: Generator capacity and stator winding capacity to ground per phase increasing cause large current circulating within the stator, which may result in severe damage to the stator insulation and earth faults in the stator. So higher requirements are needed for stator single-phase grounding protection of large generator.The paper introduces the basic principle of voltage-injection stator single-phase grounding protection and summarizes the field adjustment methods of the voltage injection scheme against the stator earth fault protection ,and gives the experimental results of adopting impedance angle mutation and transition resistance.The actual operating status for inoperative generator and that with 30% rated voltage commissioning are analyzed, and the results have verified the accuracy of setting the grounding transition resistance and selecting the fault generator.

Key words: generator, injecting source, stator ground fault protection, commissioning

中图分类号:

TM774

伍利, 彭金宁, 姚李孝, 南海鹏. 大型发电机组注入式定子接地保护调试与整定[J]. 中国电力, 2013, 46(9): 92-95.

WU Li, PNEG Jin-ning, YAO Li-xiao, NAI Hai-peng. Commissioning and Setting of Voltage-Injection Stator Ground Fault Protection for Large-sized Generator[J]. Electric Power, 2013, 46(9): 92-95.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.2013.9.92.3

https://www.electricpower.com.cn/CN/Y2013/V46/I9/92

参考文献

[1] 王翔,张成,沈全荣. 一次典型的定子接地故障分析与优化保护原理[J]. 电力系统自动化,2006,30（11）：52-55.
WANG Xiang, ZHANG Cheng, SHEN Quan-rong. Typical analysis of stator ground fault and principle of optimal protection[J]. Automation of Electric Power Systems, 2006, 30(11): 52-55.
[2] 毕大强,王祥珩,余高旺,等. 消弧线圈接地方式外加20 Hz电源定子接地保护的应用[J]. 电力系统自动化,2005,29（4）：82-84.
BI Da-qiang, WANG Xiang-heng, YU Gao-wang, et al . Application of injecting 20 Hz voltage based ground fault protection for generators grounded via Petersen-coil[J]. Automation of Electric Power Systems, 2005, 29(4): 82-84.
[3] 毕大强,王祥珩,余高旺,等. 高准确度外加20 Hz电源定子单相接地保护的研制[J]. 电力系统自动化,2004,28（16）：75-78.
BI Da-qiang, WANG Xiang-heng, YU Gao-wang, et al .Development of a high accuracy stator ground fault protection by injecting 20 Hz voltage [J]. Automation of Electric Power Systems, 2004, 28(16): 75-78.
[4] 毕大强, 王祥珩,桂林,等. 基于零序电压故障暂态分量的发电机定子单相接地保护方案研究[J]. 中国电机工程学报,2003, 23（11）：39-44.
BI Da-qiang, WANG Xiang-heng, GUI Lin, et al . Protection scheme based on the fault transient component of zero sequence voltage under the stator ground fault of generators [J]. Proceedings of the CSEE, 2003, 23(11): 39-44.
[5] PRESTON R, KANDRAC J. Report on design testing and commissioning of 100% stator ground fault protection at dominion’s bath county pumped-storage station[C]//Protective Relay Engineers Annual Conference. 2009, 62nd: 127-139.
[6] 唐云龙,赵斌,郭宝甫,等. 定子接地基波零压和20 Hz低阻保护的一些问题探讨[J]. 继电器,2007,35（12）：79-80.
TANG Yun-long, ZHAO Bin, GUO Bao-fu, et al . The discussion of zero sequence voltage and 20 Hz low resistance protection for stator grounding fault [J]. Relay, 2007, 35(12): 79-80.
[7] 兀鹏越,胡任亚,陈飞文,等. 1 036 MW机组的电气整套启动调试[J]. 电力建设,2010,31（7）：103-104.
WU Peng-yue, HU Ren-ya, CHEN Fei-wen, et al . First start-up and debugging test of complete electrical system of 1 036 MW unit [J]. Electric Power Constructions, 2010, 31(7):103-104.
[8] 毕大强,刘春秋,葛宝明. 注入式发电机定子接地保护的自适应整定[J]. 电力系统自动化,2010,34（16）：64-68.
BI Da-qiang, LIU Chun-qiu, GE Bao-ming. Self-adaptive setting for injecting source based stator ground fault protection[J].Automation of Electric Power Systems, 2010, 34(16): 64-68.
[9] 陈彦桥,薛翔宇,刘立衡,等. 大同二电厂7号机组协调控制系统优化[J]. 中国电力,2011,44（3）：69-72.
CHEN Yan-qiao, XUE Xiang-yu, LIU Li-heng, et al . Coordinated controlsystem optimization of No.7 unit in Datong 2nd Power Plant [J]. Electric Power, 2011, 44(3): 69-72.
[10] 唐芳轩,张剑. 秦山第二核电厂发电机转子引线垫条断裂故障分析[J]. 中国电力,2011,44（1）：53-55.
TANG Fang-xuan, ZHANG Jian. Fracture malfunction analysis of underlay pieces of generator rotor lead-wire of Qinshan Phase Ⅱ Nuclear Power Plant [J]. Electric Power, 2011, 44(1): 53-55.
[11] 朱晓星,刘武林,王伯春,等. 600 MW机组热工主要保护系统的分析及完善[J]. 中国电力,2010,43（3）：42-45.
ZHU Xiao-xing, LIU Wu-lin, WANG Bo-chun, et al . Analysis and optimization on the main protection system of thermal process in 600 MW units [J]. Electric Power, 2010, 43(3): 42-45.
[12] 张琦雪,陈佳胜,陈俊,等. 大型发电机注入式定子接地保护判据的改进[J]. 电力系统自动化,2008,32（3）：67-68.
ZHANG Qi-xue, CHEN Jia-sheng, CHEN Jun, et al . Improvement on criterions of stator earth fault protection with voltage injection for large-sized generators [J]. Automation of Electric Power Systems, 2008, 32(3): 67-68.
[13] 贺家李,宋从矩. 电力系统继电保护原理[M]. 增订版. 北京：中国电力出版社,2004：298-302.
[14] 范鑫,秦建明,刘静宇,等. 超临界600 MW汽轮机低负荷运行优化技术研究[J]. 中国电力,2012,45（11）：18-21.
FAN Xin, QIN Jian-ming, LIU Jing-yu, et al . Study on optimization of low load operation for supercritical 600-MW steam turbines[J].Electric Power, 2012, 45(11): 18-21.
[15] 刘小波,包明磊. 百万千瓦机组注入式定子接地保护的研究与开发[J]. 华电技术,2008,30（7）：37-41.
LIU Xiao-bo, BAO Ming-lei. The research and development on injection scheme for stator ground protection of 1 000 MW generator [J]. Huadian Technology, 2008, 30(7): 37-41.