汽轮机甩负荷对转子寿命损耗的仿真分析研究

doi:10.11930/j.issn.1004-9649.201711245

中国电力 ›› 2018, Vol. 51 ›› Issue (10): 150-155.DOI: 10.11930/j.issn.1004-9649.201711245

汽轮机甩负荷对转子寿命损耗的仿真分析研究

王立健, 何青, 李国庆

华北电力大学能源动力与机械工程学院, 北京 102206

收稿日期:2017-12-07 修回日期:2018-02-07 出版日期:2018-10-05 发布日期:2018-10-12
通讯作者: 何青(1962-),男,通信作者,教授,博士生导师,从事汽轮机状态监测技术和压缩空气储能技术研究,E-mail:hqng@163.com
作者简介:王立健(1992-),男,硕士研究生,从事汽轮机转子寿命研究和压缩空气储能技术研究,E-mail:attitudeispower@163.com
基金资助:
国家自然科学基金资助项目（No.51276059）。

Study on the Simulation of Rotor Life Loss after Unit Load Shedding

WANG Lijian, HE Qing, LI Guoqing

School of Energy Power and Mechanical Engineering, North China Electric Power University, Beijing 102206, China

Received:2017-12-07 Revised:2018-02-07 Online:2018-10-05 Published:2018-10-12
Supported by:
This work is supported by National Natural Science Foundation of China (No.51276059).

摘要/Abstract

摘要： 由于外界电网的影响或机组自身故障的原因，火力发电机组会发生机组甩负荷等恶劣的运行工况问题。针对这一问题，提出了一种在机组甩负荷情况下对转子寿命损耗情况进行估算的实时评估方法。首先建立汽轮机的动态仿真模型，实现对汽轮机甩负荷过程的动态模拟，然后通过建立的转子寿命损耗分析模块实现对转子寿命损耗的估算，并应用于1 000 MW超超临界机组甩负荷的分析。当机组发生甩负荷时，机组转速迅速升高，对转子寿命的损耗随转速的升高而增加。结果表明，甩负荷动作必然导致汽轮机转子的寿命损耗；虽然单次甩负荷动作引起的汽轮机转子的寿命损耗较小，但是对于参与调峰的大容量机组的频繁甩负荷动作，对转子寿命的累积损伤是不可忽视的。因此，可以通过该方法对在运行的汽轮机转子进行实时监控，以确保机组在安全状况下稳定运行。

关键词: 火力发电, 汽轮机甩负荷, 转子寿命损耗, 动态仿真模型, 评估方法

Abstract: Due to the influence of the external power grid or the fault of the unit itself, the units in a power plant may suffer from severe operating conditions such as load shedding. To solve this problem, in this paper, a real-time evaluation method for rotor's life loss is proposed by analyzing the unit load shedding process. First, the dynamic model of steam turbine is established to simulate the load shedding process; then the rotor life loss is estimated by the established rotor life loss analysis module, and is applied to analyze the load shedding of a 1 000 MW ultra supercritical unit. When the unit sheds a load, its speed increases rapidly, and the loss of the rotor life increases with the increase of the speed. The analysis results show that the load shedding will inevitably lead to the life loss of the turbine rotor. Although the life loss caused by a single load shedding is small, the cumulative damage to the rotor life of the large capacity regulation units which shed load frequently is significant. Therefore, the turbine's rotor can be monitored in real time by this method to ensure its stable and secure operation.

Key words: thermal power generation, steam turbine load shedding, rotor's life loss, dynamic model, evaluation method

中图分类号:

TK263.7

王立健, 何青, 李国庆. 汽轮机甩负荷对转子寿命损耗的仿真分析研究[J]. 中国电力, 2018, 51(10): 150-155.

WANG Lijian, HE Qing, LI Guoqing. Study on the Simulation of Rotor Life Loss after Unit Load Shedding[J]. Electric Power, 2018, 51(10): 150-155.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.201711245

https://www.electricpower.com.cn/CN/Y2018/V51/I10/150

参考文献

[1] 阚伟民, 胡鹏飞, 谢诞梅, 等. 1000 MW机组甩负荷转速飞升特性仿真研究[J]. 中国电力, 2014, 47(4):22-26 KAN Weimin, HU Pengfei, XIE Danmei, et al. Simulation study on 1000 MW unit speed rise during load shedding[J]. Electric Power, 2014, 47(4):22-26
[2] 王孟, 盛锦鳌, 钱海龙, 等. 660MW超临界机组100%负荷FCB功能的实现[J]. 自动化仪表, 2017(4):98-102 WANG Meng, SHENG Jinao, QIAN Hailong, et al. Implementation of 100% load FCB function of 660MW supercritical unit[J]. Process Automation Instrumentation, 2017(4):98-102
[3] 崔亚辉, 张俊杰, 顾煜炯,等. 600MW机组次同步振荡下轴系扭振校核及疲劳寿命损耗计算[J]. 热力发电, 2016, 45(7):88-92 CUI Yahui, ZHANG Junjie, GU Yujiong, et al. Research on fatigue life expenditure and torsional vibration check of a 600MW unit under subsynchronous oscillation[J]. Thermal Power Generation, 2016, 45(7):88-92
[4] NAKANO S, TSUBOUCHI K, SHIRAIWA H, et al. Load rejection tests and their dynamic simulations with a 150 kW class Microsteam turbine[J]. Journal of Engineering for Gas Turbines and Power-Transactions of the ASME, 2013, 135(5):8.
[5] 胡鹏飞, 谢诞梅, 熊扬恒. 基于DOE方法的甩负荷动态特性敏感性仿真分析[J]. 汽轮机技术, 2015, 57(6):417-421 HU Pengfei, XIE Danmei, XIONG Yangheng. Sensitivity analysis for dynamic characteristic of load rejection based on DOE method[J]. Turbine Technology, 2015, 57(6):417-421
[6] 王海涛, 刘岩, 杨彦磊. 蠕变疲劳交互作用下的高温转子寿命预测研究[J]. 热力透平, 2016, 45(4):253-258 WANG Haitao, LIU Yan, YANG Yanlei. Life prediction of high temperature turbine rotor under creep and fatigue interaction[J]. Thermal Turbine, 2016, 45(4):253-258
[7] CHEN R, HE A P, YANG Y L, et al. Life assessment technology of steam turbine rotor[C]//ASME Turbo Expo 2013:Turbine Technical Conference and Exposition. 2013:V05BT25A037.
[8] 吴勇刚. 大型火电机组汽轮机转子寿命损耗的分析与研究[J]. 现代制造, 2013(9):39-40 WU Yonggang. Analysis and research on life loss of steam turbine rotor of large thermal power units[J]. Mechanical and Electrical Information, 2013(9):39-40
[9] 吕方明, 王坤, 黄树红,等. 国产超临界汽轮机转子钢低周疲劳特性的试验研究[J]. 动力工程学报, 2013, 33(8):653-658 LV Fangming, WANG Kun, HUANG Shuhong, et al. Experimental study on low-cycle fatigue properties of domestic supercritical turbine rotor steels[J]. Chinese Journal of Power Engineering, 2013, 33(8):653-658
[10] 安欣, 李续军, 张亚夫, 等. 国产化超临界机组甩负荷试验必要性及可行性分析[J]. 现代电子技术, 2010, 33(23):181-183 AN Xin, LI Xujun, ZHANG Yafu, et al. Necessity and feasibility study of load rejection on domestic supercritical steam turbines[J]. Modern Electronics Technique, 2010, 33(23):181-183
[11] 盛锴, 魏乐, 江效龙,等. 基于PSASP和Simulink的汽轮机调节系统建模与仿真校核[J]. 中国电力, 2015, 48(2):1-6 SHENG Kai, WEI Le, JIANG Xiaolong, et al. Modeling, simulation and verification of turbine governing system based on PSASP and Simulink[J]. Electric Power, 2015, 48(2):1-6
[12] 吴锋, 徐小明, 李明武,等. 转子动力学横向振动基本方程[J]. 应用数学和力学, 2015, 36(10):1011-1018 WU Feng, XU Xiaoming, LI Mingwu, et al. The basic equation of transverse vibration for rotor dynamics[J]. Applied Mathematics and Mechanics, 2015, 36(10):1011-1018
[13] HUANG J, LI C C, YAN H, et al. A new controller design of electro-hydraulic servo system based on empirical mode decomposition[J]. Journal of Vibro Engineering, 2016, 18(2):927-937.
[14] 夏德明, 侯凯元, 安宁,等. 计及火电机组OPC保护模型的电力系统机电动态仿真分析[J]. 电力系统保护与控制, 2017, 45(4):145-149 XIA Deming, HOU Kaiyuan, AN Ning, et al. Power system electromechanical dynamic simulation considering thermal power OPC protection model[J]. Power System Protection and Control, 2017, 45(4):145-149
[15] 邓婧, 李兴源, 魏巍. 汽轮机超速保护控制系统的性能优化及其对电网频率的影响分析[J]. 电网技术, 2010, 34(12):50-56 DENG Jing, LI Xingyuan, WEI Wei. Optimization of over-speed protection controller for steam turbine and its influence on frequency of power grid[J]. Power System Technology, 2010, 34(12):50-56
[16] KANG E, SUN L, LI B, et al. A novel method for identifying large steam turbine-generator parameters by load rejection test[M]. Hong Kong:International Academic Publishers Ltd, 2005:119-123.
[17] 冯磊, 刘霞, 轩福贞. 汽轮机焊接转子残余应力模拟及其对疲劳寿命的影响[J]. 中国电机工程学报, 2014, 34(17):2851-2860 FENG Lei, LIU Xia, XUAN Fuzhen. Simulation of residual stress in welded steam turbine rotor and its effects on fatigue life[J]. Proceedings of the CSEE, 2014, 34(17):2851-2860
[18] 白云. 600MW汽轮机转子低周疲劳寿命计算及研究[D]. 长沙:长沙理工大学, 2009.
[19] 史进渊. 大功率电站汽轮机寿命预测与可靠性设计[M]. 北京:中国电力出版社, 2011.

汽轮机甩负荷对转子寿命损耗的仿真分析研究

Study on the Simulation of Rotor Life Loss after Unit Load Shedding

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	张兴平, 王腾, 张馨月, 张浩楠. 基于多智能体深度确定策略梯度算法的火力发电商竞价策略[J]. 中国电力, 2024, 57(11): 161-172.
[2]	李相俊, 马会萌, 姜倩. 新能源侧储能配置技术研究综述[J]. 中国电力, 2022, 55(1): 13-25.
[3]	仝声, 刘乐, 王鹏飞. 基于多变量广义预测控制算法的两级过热汽温协调联动控制[J]. 中国电力, 2020, 53(10): 215-223.
[4]	杨明花, 张克涵. 基于高光谱图像和卷积神经网络的燃煤热值估计算法[J]. 中国电力, 2019, 52(9): 148-153.
[5]	秦子健, 石季英, 魏文辉, 林济铿, 张新伦, 武琳. 中低压配电网综合效益评估方法研究[J]. 中国电力, 2019, 52(8): 34-44.
[6]	刘星月, 唐琳, 喻娜. 基于负荷比例的综合供能系统最优运行模式的评估方法[J]. 中国电力, 2019, 52(6): 37-44,53.
[7]	陈彬, 于继来. 强台风环境下配电线路故障概率评估方法[J]. 中国电力, 2019, 52(5): 89-95.
[8]	申旭辉, 刘建坤, 高雯曼, 张鑫, 周前. 500 kV UPFC适用场景的量化评估方法和选点方案[J]. 中国电力, 2019, 52(10): 65-71,78.
[9]	张晓东, 王鹏飞, 刘乐. 基于多变量广义预测控制算法的脱硝优化研究及应用[J]. 中国电力, 2019, 52(10): 178-184.
[10]	李金晶, 焦开明, 赵振宁, 张清峰, 孙永春. 火力发电厂配煤掺烧的燃煤成本模型[J]. 中国电力, 2018, 51(9): 15-19.
[11]	郦建国, 朱法华, 孙雪丽. 中国火电大气污染防治现状及挑战[J]. 中国电力, 2018, 51(6): 2-10.
[12]	杜振, 魏宏鸽, 张杨, 朱跃. 高效脱硫协同除尘关键技术分析[J]. 中国电力, 2018, 51(6): 37-41.
[13]	王志杰, 王锡辉, 朱晓星, 郑重. 基于模糊数风险分析法的汽轮机自启动技术研究[J]. 中国电力, 2018, 51(5): 95-100.
[14]	刘百成, 赵红民, 赫胜杰, 李华威, 李美双, 张继文. 单系列辅机在洛阳热电厂应用实践[J]. 中国电力, 2018, 51(5): 101-105.
[15]	王占洲, 曹丽华, 卫洪刚, 杨明. 风电介入对汽轮机转子寿命影响分析[J]. 中国电力, 2018, 51(4): 101-107.

模态框（Modal）标题

汽轮机甩负荷对转子寿命损耗的仿真分析研究

Study on the Simulation of Rotor Life Loss after Unit Load Shedding

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics