火电厂脱硫废水微滤、反渗透膜法深度处理试验研究

doi:10.11930/j.issn.1004-9649.2016.02.148.05

中国电力 ›› 2016, Vol. 49 ›› Issue (2): 148-152.DOI: 10.11930/j.issn.1004-9649.2016.02.148.05

火电厂脱硫废水微滤、反渗透膜法深度处理试验研究

连坤宙¹，陈景硕²，刘朝霞³，毛进¹，王璟¹，张江涛¹

1.西安热工研究院有限公司，陕西西安 710032;
2.华能国际电力股份有限公司，北京 100031;
3. 国电浙江北仑第一发电有限公司，浙江宁波 315800

收稿日期:2015-04-30 出版日期:2016-02-18 发布日期:2016-03-21
作者简介:连坤宙（1986-），男，山西运城人，工程师，从事电厂水处理技术研究。E-mail: liankunzhou@tpri.com.cn
基金资助:
华能国际电力股份有限公司科学技术项目（HNKJ14-G27）

Experimental Study on the Reduction Treatment of Desulfurization Wastewater in Power Plants by Membrane

LIAN Kunzhou¹, CHEN Jingshuo², LIU Zhaoxia³, MAO Jin¹, WANG Jing¹, ZHANG Jiangtao¹

1. Xi’an Thermal Power Research Institute Co. Ltd., Xi’an 710032, China;
2. Huaneng Power International Inc., Beijing 100031, China;
3. Guodian Beilun 1st Power Generation Co. Ltd., Ningbo 315800, China

Received:2015-04-30 Online:2016-02-18 Published:2016-03-21
Supported by:
This work is supported by Science and Technology Project of Huaneng Power International Inc (HNKJ14-G27).

摘要/Abstract

摘要： 为使电厂脱硫废水循环使用并达到废水零排放目标，采用“微滤（MF）-反渗透（RO）”工艺对预处理后的火电厂脱硫废水进行深度处理，分别考察不同固含量条件下微滤系统的运行稳定性和微滤膜的化学清洗方法，以及不同回收率条件下反渗透系统的运行稳定性和脱盐率情况。研究结果表明：经中和软化处理的脱硫废水再经微滤处理后，产水浊度小于0.2 NTU，膜污染指数SDI值小于4.0，微滤系统运行稳定；反渗透系统在不同回收率条件下运行稳定，无明显的污堵现象，系统脱盐率大于98%，单支膜的脱盐率大于99%。反渗透产水含盐量低于510 mg/L，可用作循环水补充水、脱硫工艺用水等电厂其他系统的补水。

关键词: 脱硫废水, 微滤, 反渗透, 化学清洗

Abstract: To recycle the desulfurization wastewater and achieve the goal of zero wastewater discharge in power plants, the desulfurization wastewater after pretreatment is treated by adopting microfiltration(MF) and reverse osmosis(RO). The stability of MF system and the chemical cleaning method of MF membrane under different solid content conditions are explored as well as the stability and desalination rate of RO system under different recovery rate conditions. The study results show that the MF system can operate stably and the turbidity of its water production is less than 0.2NTU with the silt density index(SDI) less than 4.0. The RO system also operates stably without obvious scaling observed under various recovery rate conditions. Its desalination rate is more than 98%, and the desalination rate of single RO membrane is more than 99%. The salinity of its water production is less than 510 mg/L, which means that the water production can be used as the make-up water for the recycled water as well as the replenishment for other systems in the power plant such as the desulfurization processing water.

Key words: desulfurization wastewater, microfiltration, reverse osmosis, chemical cleaning

中图分类号:

TM621.8
X77

连坤宙，陈景硕，刘朝霞，毛进，王璟，张江涛. 火电厂脱硫废水微滤、反渗透膜法深度处理试验研究[J]. 中国电力, 2016, 49(2): 148-152.

LIAN Kunzhou, CHEN Jingshuo, LIU Zhaoxia, MAO Jin, WANG Jing, ZHANG Jiangtao. Experimental Study on the Reduction Treatment of Desulfurization Wastewater in Power Plants by Membrane[J]. Electric Power, 2016, 49(2): 148-152.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.2016.02.148.05

https://www.electricpower.com.cn/CN/Y2016/V49/I2/148

参考文献

[1] 沈荣澍，代厚兵，杨韦. 脱硫废水常规处理及零排放技术综述[J]. 锅炉制造，２０１３，２３（２）：４４－４７．
SHEN Rongshu, DAI Houbing, YANG Wei. Desulphurization wastewater treatment and zero discharge technology[J]. Boiler Manufacturing, 2013, 23(2): 44-47.
[2] 裴俊峰，吴伟，王凤茹. 沁北电厂脱硫废水处理系统改造[J]. 电力建设，２０１０，３１（６）：８４－８６．
PEI Junfeng, WU Wei, WANG Fengru. Renovation of the desulphurization-wastewater treatment-system of Qinbei power plant [J]. Electric Power Construction, 2010, 31(6): 84-86.
[3] 吴怡为. 石灰石-石膏湿法烟气脱硫废水处理的研究[J]. 中国电力，２００６，３９（４）：７５－７８．
WU Yiwei. Study on the wastewater treatment in limestone- gypsum wet FGD process [J]. Electric Power, 2006, 39(4): 75-78.
[4] 龙国庆.燃煤电厂湿法脱硫废水蒸发结晶处理工艺的选择[J].中国给水排水，２０１３，２９（２４）：５－８．
LONG Guoqing. Selection of evaporation treatment process of wastewater form wet FGD in coal-fired power plant[J]. China Water & Wastewater, 2013, 29(24): 5-8.
[5] 王丹，蒋道利. 蒸发结晶技术在高盐废水零排放领域的应用[J]. 中国井矿盐，20１４，４５（４）：７－１０．
WANG Dan, JIANG Daoli. The application of evaporation crystallization technology in zero discharge area of high salt wastewater [J]. China Well and Rock Salt, 2014, 45(4): 7-10.
[6] 范正虹，陈福泰，陈晓婷，等. 微滤/反渗透净化污水厂二级处理出水[J]. 中国给水排水，２００５，２１（６）：４４－４６．
FAN Zhenghong, CHEN Futai, CHEN Xiaoting, et al. Microfiltration/reverse osmosis process for advanced treatment of secondary effluent from wastewater treatment plant[J]. China Water & Wastewater, 2005, 21(6): 44-46.
[7] 梁睿荣，颜幼平，姚兴. 微滤-反渗透工艺深度处理造纸废水及效果分析[J]. 水污染防治，２０１４，６（９）：３３－３７．
LIANG Ruirong, YAN Youping, YAO Xing. Study on microfiltration-reverse osmosis membrane process for advanced treatment of papermaking wastewater[J]. Water Pollution Control, 2014, 6(9): 33-37.
[8] 徐竟成，朱清漪，李光明，等. 印染废水微滤-反渗透工艺深度处理研究[J]. 印染，２００８，１７（５）：２４－２７．
XU Jingcheng, ZHU Qingyi, LI Guangming, et al. Dyeing wastewater reuse by means of microfiltration reverse osmosis combined process [J]. Dyeing & Finishing, 2008, 17(5): 24-27.
[9] 李江，郑东晟，杨昆，等. 微滤-反渗透技术在城市园区污水再生回收中的应用[J]. 膜科学与技术，２０１３，３３（４）：１２０－１２４．
LI Jiang, ZHENG Dongsheng, YANG Kun, et al. Application of micro filtration-reverse osmosis in wastewater reclamation and reuse in the urban park[J]. Membrane Science and Technology, 2013, 33(4): 120-124.
[10] 程相利. 火力发电厂亚临界压力锅炉用水除硅研究[D]. 北京：北京科技大学，2001.
[11] LATOUR I, MIRANDA R, BLANCO A. Silica removal in industrial effluents with high silica content and low hardness[J]. Environmental Science and Pollution Research, 2014, 21(16): 9832-9842.
[12] SAKOL D, KONIECZNY K. Application of coagulation and conventional filtration in raw water preatment before microfiltration membranes [J]. Desalination, 2004, 162: 61-73
[13] SCHAFER A I, FANE A G, WAITE T D. Fouling effects on rejection in the membrane filtration of natural waters[J]. Desalination, 2000, 131: 215-224.
[14] GUO W S, VIGNESWARAN S, NGO H H. Effect of flocculation and/or adsortion as pretreatment on the critical flux of crossflow microfiltration [J]. Desalination, 2005, 172: 53-62.
[15] 韦贵菊，刘广庆，戴海平，等. 微滤膜清洗的研究[J]. 天津工业大学学报，2００５，２４（５）：５７－５９．
WEI Guiju, LIU Guangqing, DAI Haiping, et al. Study of cleaning microfiltration membranes [J]. Journal of Tianjin Institute of Textile Science and Technology, 2005, 24(5): 57-59.
[16] 郭建，邓超冰，冼萍，等. “微滤+反渗透”工艺在处理垃圾渗滤液中的应用研究[J]. 环境科学与技术，２０１１，３４（５）：１７０－１７４．
（下转第175页）

火电厂脱硫废水微滤、反渗透膜法深度处理试验研究

Experimental Study on the Reduction Treatment of Desulfurization Wastewater in Power Plants by Membrane

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	赵宁, 冯永新, 林廷坤, 杨青山, 谢志文. 脱硫废水旋转喷雾蒸发与旁路烟道蒸发特性研究[J]. 中国电力, 2022, 55(7): 193-200.
[2]	李飞. 旋转雾化蒸发技术对脱硫废水和烟气的适应性研究[J]. 中国电力, 2021, 54(4): 213-220.
[3]	李飞, 陈海杰, 刘峰均, 谷小兵, 车广民, 白玉勇, 杨林军. 脱硫废水旋转喷雾蒸发特性实验研究[J]. 中国电力, 2021, 54(1): 188-195.
[4]	杨阳, 胡大龙, 黄倩, 许臻, 王璟, 吴火强, 王博. 火电厂废水排放控制政策法规与技术路线综述[J]. 中国电力, 2020, 53(8): 131-138.
[5]	贾西部. 石灰石-石膏湿法脱硫废水排放量深度解析[J]. 中国电力, 2020, 53(8): 139-144,163.
[6]	王晋权, 赵周明, 张志华. 低温余热闪蒸脱硫废水处理系统设计及应用[J]. 中国电力, 2020, 53(8): 151-157,181.
[7]	赵舒然, 韩小渠, 张丹, 刘继平. 燃煤电厂脱硫废水热法零排放技术热成本分析[J]. 中国电力, 2020, 53(7): 184-188,196.
[8]	张千, 倪黎, 豆朝宗, 肖海平. 脱硫废水处理前后喷射Cl析出特性[J]. 中国电力, 2020, 53(7): 197-202.
[9]	王文欣, 高毅, 刘春红, 童小忠, 陈彪, 祁志福, 张勤. 燃煤电厂旁路烟气干燥塔控制技术开发[J]. 中国电力, 2020, 53(1): 147-154.
[10]	晋银佳, 刘泽宇, 尤良洲, 夏守庆, 唐国瑞. RESALT技术在燃煤电厂脱硫废水浓缩处理中的应用[J]. 中国电力, 2019, 52(7): 154-160.
[11]	佘晓利, 潘卫国, 王程瑶, 倪迎春, 秦岭. 脱硫废水旁路塔雾化蒸发数值模拟[J]. 中国电力, 2019, 52(1): 129-136.
[12]	朱懿灏, 赵晓丹, 田小测, 吴军辉, 窦微笑, 周振. 脱硫废水处理系统污泥资源化除磷技术研究[J]. 中国电力, 2019, 52(1): 137-143.
[13]	吴智泉, 曹蕃, 袁园, 贾西部. 脱硫废水烟道蒸发工艺对烟气酸露点影响分析[J]. 中国电力, 2019, 52(1): 151-155,184.
[14]	连坤宙, 胡特立, 王永前, 焦绪常, 王璟, 曹红梅, 毛进, 樊开远. 燃煤电厂脱硫废水预处理装置设计与中试研究[J]. 中国电力, 2018, 51(6): 166-171.
[15]	翁卫国, 孙建国, 李钦武, 周灿, 蒋善行. 脱硫废水零排放系统关键参数数值模拟研究[J]. 中国电力, 2018, 51(6): 42-47.

模态框（Modal）标题

火电厂脱硫废水微滤、反渗透膜法深度处理试验研究

Experimental Study on the Reduction Treatment of Desulfurization Wastewater in Power Plants by Membrane

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics