辅机统调动力源系统在某660 MW机组的应用

doi:10.11930/j.issn.1004-9649.201705052

中国电力 ›› 2018, Vol. 51 ›› Issue (9): 65-72.DOI: 10.11930/j.issn.1004-9649.201705052

辅机统调动力源系统在某660 MW机组的应用

牟春华¹, 吕凯^1,2, 许朋江^1,2, 孙大伟¹, 兀鹏越¹, 马汀山^1,2, 居文平^1,2, 李冬泉³

1. 西安热工研究院有限公司, 陕西西安 710054;
2. 西安西热节能技术有限公司, 陕西西安 710054;
3. 华能威海发电有限责任公司, 山东威海 264299

收稿日期:2017-05-15 修回日期:2018-06-22 出版日期:2018-09-05 发布日期:2018-09-20
通讯作者: 吕凯(1985-),男,工程师,lvkai@tpri.com.cn,15891731998
作者简介:牟春华(1964-),男,高级工程师,从事燃煤电站节能减排理论与技术研究,E-mail:muchunhua@tpri.com.cn
基金资助:
中国华能集团公司总部科技项目（HNKJ15-H09）。

Application of Unified Power-Regulating System of Auxiliary Equipment on a 660 MW Unit

MU Chunhua¹, LV Kai^1,2, XU Pengjiang^1,2, SUN Dawei¹, WU Pengyue¹, MA Tingshan^1,2, JU Wenping^1,2, LI Dongquan³

1. Xi'an Thermal Power Research Institute Co., Ltd., Xi'an 710054, China;
2. Xi'an TPRI Energy Conservation Technology Co., Ltd., Xi'an 710054, China;
3. Huaneng Weihai Power Generation Co., Ltd., Weihai 264299, China

Received:2017-05-15 Revised:2018-06-22 Online:2018-09-05 Published:2018-09-20
Supported by:
This work is supported by Science and Technology Project of China Huaneng Group (No.HNKJ15-H09).

摘要/Abstract

摘要： 以高转速变转速汽轮机和变频发电机为主组成的统调动力源系统，统一调节最佳运行频率比较一致的主要辅机设备，在减小系统节流损失提高传动效率的同时，系统更为集中、简单，便于维护。某660 MW机组采用变频驱动锅炉风机的统调动力源系统，通过性能试验掌握了系统运行特性，得到了不同负荷下最佳运行方式。THA、75%THA和50%THA工况最佳频率分别为47 Hz、41 Hz和41 Hz。在频率41~50 Hz范围内，统调动力源系统最优频率运行下机组供电煤耗较改造前风机工频运行状态下略有下降或基本持平，较变频运行状态略有增加，但厂用电率显著降低，机组净供电能力明显提升。随着运行频率降低，引风机、一次风机和送风机的运行效率有不同程度的提高。三大风机总耗功随运行频率呈近似线性关系：运行频率自50 Hz降低至最佳点，THA、75%THA和50%THA工况下总耗功分别降低了308 kW、816 kW和868 kW。

关键词: 燃煤发电机组, 高转速变转速汽轮机, 变频发电机, 统调动力源系统, 统一调节, 运行效率, 供电煤耗

Abstract: The unified power-regulating system of auxiliary equipment (UPRS), which is mainly composed of variable-high-speed turbine and variable-frequency generator, adjusts the main auxiliary equipment with the same optimum operating frequency. It reduces the throttle loss of the system and improves the transmission efficiency, while the system is more centralized, simple and easy to maintain. A power source system of boiler fan driven by frequency conversion is adopted in a 660MW unit. The operating characteristics of the system are figured out through performance tests, and the optimal operating modes under different loads are also obtained. The best operating frequencies under THA, 75%THA and 50%THA operating conditions are 47Hz, 41Hz and 41Hz, respectively. Within the range of frequency 41~50Hz, the coal consumption of the unit when the power source system is operated under the optimal frequency is slightly less than or basically equal to that under the operation frequency before the transformation, and is slightly more than that with the variable frequency operation state, but the power consumption rate of the unit decreases significantly, and the net power supply capacity is also significantly improved. With the decrease of operating frequency, the efficiency of induced fan, primary fan and blower are improved to some extent. The total power consumption of the three blower fans is approximately linear with the operating frequency. The operating frequency is reduced from 50Hz to the optimal point, the total energy consumption is reduced by 308kW/816kW and 868kW respectively under the condition of 75THA and 50%THA.

Key words: coal-fired power units, variable-high-speed turbine, variable-frequency generator, unified power-regulating system of auxiliary equipment, uniformly regulate, operating efficiency, coal consumption of power supply

中图分类号:

TK01
TM621

牟春华, 吕凯, 许朋江, 孙大伟, 兀鹏越, 马汀山, 居文平, 李冬泉. 辅机统调动力源系统在某660 MW机组的应用[J]. 中国电力, 2018, 51(9): 65-72.

MU Chunhua, LV Kai, XU Pengjiang, SUN Dawei, WU Pengyue, MA Tingshan, JU Wenping, LI Dongquan. Application of Unified Power-Regulating System of Auxiliary Equipment on a 660 MW Unit[J]. Electric Power, 2018, 51(9): 65-72.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.201705052

https://www.electricpower.com.cn/CN/Y2018/V51/I9/65

参考文献

[1] 王勇. 330 MW机组电动给水泵改汽动给水泵的研究与实践[D]. 北京:华北电力大学, 2014. WANG Yong. Study and practice of the driving mode of feed water pumps for 330 MW units[D]. Beijing:North China Electric Power University, 2014.
[2] 段栋伟, 徐钢, 刘琦, 等. 600 MW亚临界空冷机组电泵改汽泵性能评估[J]. 电站系统工程, 2017, 33(1):29-33 DUAN Dongwei, XU Gang, LIU Qi, et al. The performance evaluation of electric pump to steam pump for 600 MW subcritical air cooling unit[J]. Power System Engineering, 2017, 33(1):29-33
[3] 王宽. 大型发电厂引风机驱动方式改造的技术经济研究[D]. 杭州:浙江大学, 2013. WANG Kuan. Study on technical economy of the driven mode of induced draft fan for large power plant[D]. Hangzhou:Zhejiang University, 2013.
[4] 谭灿燊, 吴阿峰. 电站锅炉引风机驱动方式的分析比较[J]. 热力发电, 2012, 41(8):12-14 TAN Canshen, WU Afeng. Analysis and comparison of driven mode for induced draft fan in thermal power plant[J]. Thermal Power Generation, 2012, 41(8):12-14
[5] 金蓉, 石奇光, 杨燕玲, 等. 考虑管道热效率的汽动引风机选择方案[J]. 热力发电, 2013, 42(1):5-8 JIN Rong, SHI Qiguang, YANG Yanling, et al. Selection of steam-driven induced draft fan considering piping thermal efficiency[J]. Thermal Power Generation, 2013, 42(1):5-8
[6] 刘桂生, 马骏驰, 丁平, 等. 循环水泵电动机双速改造[J]. 热力发电, 2008, 37(2):66-67 LIU Guisheng, MA Junchi, DING Ping, et al. Retrofitting electric motor of circulating water pump into a double-speed one[J]. Thermal Power Generation, 2008, 37(2):66-67
[7] 宋晓卓. 某自备电厂锅炉风机的变频改造分析[D]. 西安:西安工程大学, 2015. SONG Xiaozhuo. Operating transformation analysis on the fans for boiler in a personal used power plant[D]. Xi'an:Xi'an Polytechnic University, 2015.
[8] 毛刚, 汤载阳. 动叶可调引风机变频改造的经济性论证[J]. 电力勘测设计, 2015(2):44-46,64 MAO Gang, TANG Zaiyang. Economic argumentation of variable frequency reconstruction for axial fan with adjustable blades[J]. Electric Power Survey & Design, 2015(2):44-46,64
[9] 曹磊. 火力发电厂高压电动机变频改造及其安全性经济性分析[D]. 济南:山东大学, 2015. CAO Lei. The variable-frequency renovation for high-voltage motors and its safety and economy analysis in coal-fired power plant[D]. Jinan:Shandong University, 2015.
[10] 梅德奇, 张福仲. 亚临界600 MW空冷机组凝结水泵变频改造[J]. 热力发电, 2013, 42(1):103-104,108 MEI Deqi, ZHANG Fuzhong. Frequency conversion transformation of condensate pump for a 600 MW subcritical air-cooled unit[J]. Thermal Power Generation, 2013, 42(1):103-104,108
[11] 盛喜兵, 李振强, 杜化仲, 等. 330 MW机组凝结水泵变频改造及系统运行优化[J]. 热力发电, 2011, 40(9):86-88 SHENG Xibing, LI Zhenqiang, DU Huazhong, et al. Frequency conversion retrofit of condensate pump for 330 MW unit and system operation optimization thereof[J]. Thermal Power Generation, 2011, 40(9):86-88
[12] 翟慎会, 胡训栋, 高永芬, 等. 汽轮机同轴驱动给水泵传动装置的研究[J]. 电站系统工程, 2014, 30(1):42-44 ZHAI Shenhui, HU Xundong, GAO Yongfen, et al. Research on transmissions of feed water pump coaxially driven by turbine[J]. Power System Engineering, 2014, 30(1):42-44
[13] 欧卫海. 液偶调速电动给水泵节能改造方案解析-行星齿轮变矩调速器与变频器方案对比[J]. 南方能源建设, 2016, 3(S1):21-26 OU Weihai. Boiler feedwater pump hydraulic coupler energy saving retrofit scheme:compare of planetary gear torque speed solution and variable frequency drive solution[J]. Southern Energy Construction, 2016, 3(S1):21-26
[14] 徐光涛. 行星齿轮调速器在660 MWe超临界空冷机组电动给水泵上的应用[J]. 电力技术, 2010, 19(8):43-46
[15] 章世斌, 蒋庆群, 张贵良, 等. 永磁驱动调速技术在引风机改造中的应用[J]. 热力发电, 2014, 43(5):135-138 ZHANG Shibin, JIANG Qingqun, ZHANG Guiliang, et al. Application of permanent magnetic speed control technology in ID fan retrofitting[J]. Thermal Power Generation, 2014, 43(5):135-138
[16] 王洪滨, 刘文华, 杜江, 等. 永磁调速节能技术在大功率循环水泵上的应用[J]. 节能技术, 2012, 32(2):178-181 WANG Hongbin, LIU Wenhua, DU Jiang, et al. Applications of permanent magnet speed control energy-saving technology for high-power circulating water pumps[J]. Energy Conservation Technology, 2012, 32(2):178-181
[17] 华能威海发电有限责任公司6号机组节能先进技术集成应用及示范项目改造效果分析报告[R]. 西安:西安热工研究院有限公司, 2016:1-11.

辅机统调动力源系统在某660 MW机组的应用

Application of Unified Power-Regulating System of Auxiliary Equipment on a 660 MW Unit

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	陈欢乐, 归一数, 陈伟, 王阳, 卢宏林, 明磊. 基于加热器切除的深度调频控制技术研究与实施[J]. 中国电力, 2021, 54(3): 168-176.
[2]	伦涛, 鄂志君, 张利, 王鑫, 赵永亮, 严俊杰. 燃煤机组不同灵活性调节方案参与一次调频过程的经济性分析[J]. 中国电力, 2019, 52(8): 164-172.
[3]	王天堃. 基于神经网络模型及预测控制DMC的火电机组脱硝控制策略[J]. 中国电力, 2019, 52(12): 140-145.
[4]	刘福国, 张绪辉, 吴举, 崔福兴. 基于数据校正的电厂日常供电煤耗诊断分析[J]. 中国电力, 2019, 52(11): 118-124.
[5]	孙友源, 郑张, 秦亚琦, 郭振, 任健. 火电机组碳排放特性研究及管理建议[J]. 中国电力, 2018, 51(3): 144-149,169.
[6]	徐星, 谭锐, 李永生, 蔡培, 黄启龙, 马晓峰. 1 000 MW超超临界二次再热机组一次调频方式分析[J]. 中国电力, 2018, 51(2): 169-175.
[7]	关玉衡, 汪隆君, 孙川, 张跃, 张俊潇. 考虑地区差异的电网设备运行效率评估[J]. 中国电力, 2018, 51(2): 61-66.
[8]	归一数, 沈丛奇, 陈欢乐, 程际云, 王念龙, 唐龙胜, 刘刚, 陈元良. 火电燃煤机组大频差一次调频性能研究与优化实施[J]. 中国电力, 2017, 50(4): 106-112.
[9]	黄香彬, 汪华剑, 白鹏, 严响林. 少油点火燃烧器运行优化数值模拟[J]. 中国电力, 2017, 50(10): 104-109.
[10]	刘磊, 张秋生, 吴志刚, 王富强, 张金营. 1 000 MW超超临界机组高压旁路异动分析[J]. 中国电力, 2016, 49(9): 87-92.
[11]	樊印龙, 张宝, 顾正皓, 秦攀, 吴文健. 节流配汽汽轮机组一次调频经济代价分析[J]. 中国电力, 2016, 49(7): 86-89.
[12]	孙栓柱，江叶峰，代家元，周挺，周春蕾. 燃煤机组网源互动可调出力在线监测模型研究与应用[J]. 中国电力, 2016, 49(12): 81-85.
[13]	彭祖辉，孙栓柱，代家元. 火电机组节能发电调度决策支持系统研究与开发[J]. 中国电力, 2014, 47(5): 107-112.
[14]	杜和冲, 吴克锋, 申建东, 袁德刚, 李大才. 烟气深度冷却系统在1 000 MW超超临界机组的应用[J]. 中国电力, 2014, 47(4): 32-37.
[15]	刘培忠，杨志军. 高寒地区间接空冷机组散热器防冻预暖措施[J]. 中国电力, 2013, 46(5): 18-22.

模态框（Modal）标题

辅机统调动力源系统在某660 MW机组的应用

Application of Unified Power-Regulating System of Auxiliary Equipment on a 660 MW Unit

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics