循环流化床一、二次风管网特性及风机选型研究

doi:10.11930/j.issn.1004-9649.2012.10.36.5

中国电力 ›› 2012, Vol. 45 ›› Issue (10): 36-41.DOI: 10.11930/j.issn.1004-9649.2012.10.36.5

循环流化床一、二次风管网特性及风机选型研究

王泉海¹, 卢啸风¹, 鲁佳易¹, 张文清², 辛胜伟², 刘昌旭², 李林²

1. 重庆大学低品位能源利用技术及系统教育部重点实验室,重庆 400044;
2. 四川白马循环流化床示范电站有限责任公司,四川内江 641005

收稿日期:2012-08-12 出版日期:2012-10-18 发布日期:2016-02-29
作者简介:王泉海（1974-）,男,江西广丰人,博士,讲师,主要从事污染物形成机理及综合治理、燃烧过程中矿物质的行为特性、汞迁徙和排放控制及模拟等研究工作。
基金资助:
教育部留学回国人员启动基金资助项目; 高等学校博士学科点专项科研基金资助项目（20100191120017）; 重庆市科委科技计划攻关一般项目（CSTC2011BA4068）

Study on Pipeline Characteristics and Selection of Primary and Secondary Air Fans for CFB Boilers

WANG Quan-hai¹, LU Xiao-feng¹, LU Jia-yi¹, ZHANG Wen-qing², XIN Sheng-wei², LIU Chang-xv², LI Lin³

1. Key Laboratory of Low-grade Energy Utilization Technologies and Systems (Chongqing University), Ministry of Education, Chongqing 400044, China;
2. Sichuan Baima CFB Demonstration Power Plant Co. Ltd. Neijiang 641005, China

Received:2012-08-12 Online:2012-10-18 Published:2016-02-29

摘要/Abstract

摘要： 通过分析循环流化床（circulating fluidized bed,CFB）锅炉一、二次风的管网特性,并结合电站CFB锅炉的运行参数,对大型CFB锅炉一、二次风机的选型进行了研究。结果表明：CFB锅炉一次风所需最大风量与最高压头不在同一工作点上,具有与煤粉锅炉一次风完全不同的管网特性。CFB锅炉二次风的管网特性与煤粉锅炉二次风的管网特性类似,不同之处在于其管网阻力中增加了由炉内颗粒浓度产生的压降;CFB锅炉一次风机选型时应使管网特性曲线完全落在风机的性能曲线内,并采用能耗较低的变速调节或入口导叶调节。CFB锅炉二次风机选型原则与普通离心风机选型原则类似,但应估计出由颗粒浓度所产生压降的大小,对300 MW CFB机组来说,其值在5.5~7.5 kPa范围内。

关键词: 火电厂, 循环流化床, 管网特性, 风机选型

Abstract: Through analyzing the pipeline characteristics of the primary air and secondary air on circulating fluidized bed （CFB） along with several operating data from commercial CFB boilers, the selection principles of primary air fan and secondary air fan are studied. The results indicate that the maximum air flow and maximum pressure head of the primary air of a CFB boiler are not at the same operating point, forming a pipeline characteristic completely different from that of a pulverized coal boiler. The pipeline characteristic of the secondary air of a CFB boiler is similar to that of a pulverized coal boiler, but with the pressure drop produced by the particle concentration in the furnace added to the system resistance. When a primary air fan is selected for CFB boilers, the pipeline characteristic curve should be entirely included by the fan performance curve, and inlet guide vane adjustment or variable speed adjustment of lower energy consumption should be adopted. The selection principle of the secondary air fan for the CFB boiler is similar to that of the centrifugal fan with the pressure drop caused by bed materials beingestimated. For 300-MW CFB units, the pressure drop is usually between 5.5 kPa and 7.5 kPa.

Key words: thermal power plant, circulating fluidized bed, pipeline characteristic, selection principle

中图分类号:

TK229.6

王泉海, 卢啸风, 鲁佳易, 张文清, 辛胜伟, 刘昌旭, 李林. 循环流化床一、二次风管网特性及风机选型研究[J]. 中国电力, 2012, 45(10): 36-41.

WANG Quan-hai, LU Xiao-feng, LU Jia-yi, ZHANG Wen-qing, XIN Sheng-wei, LIU Chang-xv, LI Lin. Study on Pipeline Characteristics and Selection of Primary and Secondary Air Fans for CFB Boilers[J]. Electric Power, 2012, 45(10): 36-41.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.2012.10.36.5

https://www.electricpower.com.cn/CN/Y2012/V45/I10/36

参考文献

[1] YUE Guang-xi, YANG Hai-rui, LU Jun-fu, et al . Latest development of CFB boilers in China[C]// 20th International Conference on Fluidized Bed Combustion, Xi’an, China, 2009.
[2] Beér J M. High efficiency electric power generation: The environmental role[J]. Progress in Energy and Combustion Science, 2007,33(2): 107-134.
[3] 蒋敏华,肖平.大型循环流化床锅炉技术[M].北京：中国电力出版社,2009: 270-292.
JIANG Min-hua, XIAO Ping. Large-scale circulating fluidized bed boiler technology[M]. Beijing: China Electric Power Press, 2009:270-292.
[4] 苏建民.基于流态重构的循环流化床锅炉节能燃烧技术的应用实践[J].动力工程学报,2011,31(3)：170-175.
SU Jian-min. Application practices of energy saving combustion technologies for circulating fluidized bed boiler based on flow pattern reconstruction[J]. Journal of Chinese Society of Power Engineering,2011,31(3): 170-175.
[5] YANG Hai-rui, ZHANG Hai, YANG Shi, et al . Effect of bed pressure drop on performance of a CFB boiler[J]. Energy Fuels,2009, 23(9): 2886-2890.
[6] 张缦,别如山.1 025 t/h等级循环流化床锅炉一次风机参数确定[J].中国电力,2009,42(3): 44-47.
ZHANG Man, BIE Ru-shan. Parameter determination of primary air fan for 1 025 t/h-class CFB boiler[J]. Electric Power, 2009,42(3): 44-47.
[7] 刘家钰,孙献斌.国产化300 MW机组CFB锅炉一次风机选型研究[J].中国电力,2005,38(8): 74-76.
LIU Jia-yu, SUN Xian-bin. Type selection for the primary air fans used in domestic 300 MW CFB boilers [J]. Electric Power, 2005, 38(8):74-76.
[8] 杨诗成,王喜魁.泵与风机[M].北京：中国电力出版社,2006:143-144.
YANG Shi-cheng, WANG Xi-kui. Pumps and fans[M].Beijing: China Electric Power Press, 2006: 143-144.
[9] BAYOMI N N, ABODEL HAFIZ A, OSMAN A M. Effect of inlet straighteners on centrifugal fan performance[J].Energy Conversion and Management,2006,47(18):3307-3318.
[10] LI Chun-xi, WANG Song-ling, JIA Ya-kui. The performance of a centrifugal fan with enlarged impeller[J].Energy Conversion and Management,2011,52(8):2902-2910.
[11] QI Da-tong, MAO Yi-jun, LIU Xiao-liang, et al . Experimental study on the noise reduction of an industrial forward-curved blades centrifugal fan[J]. Applied Acoustics, 2009, 70(8): 1041-1050.
[12] KAZEMPOUR L H, MEHDIZADEH M, AKBARI G M, et al . Corrosion and fatigue failure analysis of a forced draft fan blade[J]. Engineering Failure Analysis,2011,18(4):1193-1202.
[13] 郑毅,付祥卫.循环流化床锅炉风机选型探讨[J].东北电力大学学报,2007,27(6)：96-100.
ZHENG Yi, FU Xiang-wei. Discussion on model choices of fans for circulating fiuidized bed boiler[J]. Journal of Northeast Dianli University,2007,27(6):96-100.
[14] 李前宇,赵凯,梅东升,等. 300MW CFB锅炉一次风机选型原则探讨[J].热力发电,2010,39(2)：56-58.
LI Qian-yu, ZHAO Kai, MEI Dong-sheng, et al . An approach to type selection principle of primary air fans for CFB boiler of 300 MW unit[J]. Thermal Power Generation,2010,39(2):56-58.
[15] 冯俊凯,岳光溪,吕俊复.循环流化床燃烧锅炉[M].北京：中国电力出版社,2003：39-46.
FENG Jun-kai, YUE Guang-xi, LU Jun-fu. Circulating fluidized bed combustion boiler[M]. Beijing: China Electric Power Press,2003: 39-46.
[16] PALLARÉS D, JOHNSSON F. Macroscopic modelling of fluid dynamics in large-scale circulating fluidized beds[J]. Progress in Energy and Combustion Science,2006,32(5):539-569.
[17] YANG Hai-rui, YUE Guang-xi, XIAO Xianbin, et al . 1D modeling on the material balance in CFB boiler[J]. Chemical Engineering Science, 2005,60(20): 5603-5611.

循环流化床一、二次风管网特性及风机选型研究

Study on Pipeline Characteristics and Selection of Primary and Secondary Air Fans for CFB Boilers

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	刘习文, 彭卓寅, 胡新强, 叶泽, 何会学, 蔡睿, 魏文博. 燃煤火电厂年度燃料成本最小化决策模型及应用[J]. 中国电力, 2022, 55(6): 202-207.
[2]	王鹏程, 邓博宇, 蔡晋, 王珂, 孔皓, 李丽锋, 张缦, 杨海瑞. 超临界循环流化床锅炉深度调峰技术难点及控制策略[J]. 中国电力, 2021, 54(5): 206-212.
[3]	晏敏, 张杨, 郭博闻, 朱跃. 基于全寿命周期成本的SCR脱硝系统优化分析[J]. 中国电力, 2021, 54(3): 191-196.
[4]	杨阳, 胡大龙, 黄倩, 许臻, 王璟, 吴火强, 王博. 火电厂废水排放控制政策法规与技术路线综述[J]. 中国电力, 2020, 53(8): 131-138.
[5]	邓宇强, 齐佶, 王启亮, 祁东东, 宋飞, 李海洋, 程家庆, 王冬梅, 马彦斌. 停用保护剂对锅炉启停期间水汽中TOCi的影响研究[J]. 中国电力, 2020, 53(6): 161-165,196.
[6]	王霂晗, 朱林, 张晶杰, 杨帆. 欧盟火电厂二氧化碳排放在线监测系统质量保证体系对中国的启示[J]. 中国电力, 2020, 53(3): 154-158,176.
[7]	唐伟峰, 张佳琦, 李飞. 无磷阻垢剂WS330海水循环冷却阻垢试验研究[J]. 中国电力, 2019, 52(9): 161-166,178.
[8]	赵秀勇, 朱法华, 王圣, 孙雪丽, 徐静馨. 江苏省火电超低排放对环境空气中PM_2.5质量浓度影响模拟研究[J]. 中国电力, 2019, 52(9): 167-172.
[9]	李昊燃, 徐永峰, 马翔. 大型电站烟风管道节能优化及工程应用[J]. 中国电力, 2019, 52(7): 123-131.
[10]	段旭晨, 彭道刚, 姚峻, 赵慧荣, 夏飞. 基于SA-PSO-AHP的火电厂控制系统信息安全威胁评估[J]. 中国电力, 2019, 52(5): 29-35.
[11]	庞乐, 赵玉柱, 张帅, 李鹏. 加装低压省煤器对汽轮机排汽量的影响研究[J]. 中国电力, 2019, 52(4): 133-137.
[12]	韩超, 马欣欣, 沈维春, 董士波, 王秀娜, 曹旭, 徐剑锋. 智慧安全系统在火电厂中的应用研究[J]. 中国电力, 2019, 52(3): 127-132.
[13]	李玉宇, 吴火强, 余伟权, 毛进, 连坤宙. 珠海电厂精处理系统再生废水综合利用改造方案[J]. 中国电力, 2019, 52(3): 140-145.
[14]	肖育军, 邹毅辉, 李彩亭, 周雪斌. SCR系统结构模型与数值模型的适用性分析[J]. 中国电力, 2019, 52(3): 146-152,160.
[15]	张楚, 杨毅, 金格, 刘石, 高庆水. 循环水泵动态镜板翘曲故障诊断及振动评价讨论[J]. 中国电力, 2019, 52(2): 144-148,177.

模态框（Modal）标题

循环流化床一、二次风管网特性及风机选型研究

Study on Pipeline Characteristics and Selection of Primary and Secondary Air Fans for CFB Boilers

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics