乙醇胺汽液分配系数及高温分解特性的试验研究

doi:10.11930/j.issn.1004-9649.201708272

中国电力 ›› 2018, Vol. 51 ›› Issue (5): 128-133.DOI: 10.11930/j.issn.1004-9649.201708272

乙醇胺汽液分配系数及高温分解特性的试验研究

朱志平^1,3, 杨磊^1,3, 乔越^1,3, 曹颉^1,3, 赵永福²

1. 长沙理工大学化学与生物工程学院, 湖南长沙 410114;
2. 中国核动力研究设计院, 四川成都 610041;
3. 电力与交通材料保护湖南省重点试验室, 湖南长沙 410114

收稿日期:2017-09-22 修回日期:2017-12-27 出版日期:2018-05-05 发布日期:2018-05-07
作者简介:朱志平(1963-),男,湖北天门人,博士,教授,从事热力设备腐蚀与防护及锅炉(含核电)水化学优化研究工作,E-mail:zzp8389@163.com
基金资助:
国家重大科技专项资助项目（2011ZX06004-017）；湖南省科技计划重点资助项目（2013GK2006））。

Experimental Study on Gas-Liquid Partition Coefficient and Thermal Decomposition Characteristics of Ethanolamine in High-Temperature Aqueous Systems

ZHU Zhiping^1,3, YANG Lei^1,3, QIAO Yue^1,3, CAO Jie^1,3, ZHAO Yongfu²

1. School of chemical and biological engineering, Changsha University of Science and Technology, Changsha 410114, China;
2. Nuclear Power Institute of China, Chengdu 610041, China;
3. Hunan Provincial Key Laboratory of Materials Protection for Electric Power and Transportation, Changsha 410114, China

Received:2017-09-22 Revised:2017-12-27 Online:2018-05-05 Published:2018-05-07
Supported by:
This work is supported by the National Key Project of Science and Technology (No.2011ZX06004-017) and Hunan Province Science & Technology Key Grant Project Foundation (No.2013GK2006).

摘要/Abstract

摘要： 中国第三代核电选定乙醇胺（ETA）作为二回路碱化剂，但目前有关ETA汽液分配系数、高温分解特性研究不够全面，难以满足各种参数核电站的应用需求。采用高压釜模拟核电站二回路的工作压力与温度，采用特制取样装置得到了试验中汽、液两相样品，利用离子色谱、总有机碳（TOC）分析等手段研究了汽、液两相样品在不同温度下相对挥发度、热分解率及TOC含量；同时提出汽相总碱与液相总碱浓度比计算公式，用以评价汽液两相碱化剂的分布状况。研究结果表明：ETA汽液分配系数低，有利于提高二回路系统液相的pH值。在无氧条件下ETA的热稳定性好，即使300℃下热分解率也不超过1.0%/h；但含氧会加速ETA分解，其分解产物中存在较高质量浓度的铵根和较低质量浓度的甲酸、乙酸和乙醇酸。所得试验数据可以作为核电站二回路水化学控制参考依据。

关键词: 乙醇胺, 汽液分配系数, 相对挥发度, 热分解, 核电站, 二回路

Abstract: Ethanolamine (ETA) has been selected as the pH control agent for the secondary loop in the third generation nuclear power plant. However, the research on ETA gas-liquid partition coefficient and high-temperature degradation is not comprehensive enough to satisfy the application requirements of various parameters in nuclear power plant. In this paper, the working pressure and temperature of the secondary loop of nuclear power plant are simulated by high-pressure autoclave. The gas and liquid samples are obtained by special sampling device. The relative volatility, thermal decomposition rate and total organic carbon (TOC) content of samples at different temperatures are studied by ion chromatography and TOC analysis methods. The calculating formula for the molar ratio of total alkali in gas phase to total alkali in liquid phase is proposed to evaluate the distribution of gas-liquid alkalinity. It is indicated that the lower distribution coefficient of ETA is beneficial to the pH balance of the secondary loop. ETA exhibits good thermal stability under the oxygen-free condition, with the thermal decomposition rate less than 1%/h even at 300℃. But the thermal degradation rate of ETA increases in the presence of oxygen, with higher concentration of ammonia ion and lower content of formic acid, acetic acid and glycolic acid in the decomposition product. The experimental results can provide the reference for the chemical control of cycle water chemistry in nuclear power plant.

Key words: ethanolamine, gas-liquid partition coefficient, relative volatility, thermal decomposition, nuclear power plant, second recirculation loop

中图分类号:

TL48
TM621.8

朱志平, 杨磊, 乔越, 曹颉, 赵永福. 乙醇胺汽液分配系数及高温分解特性的试验研究[J]. 中国电力, 2018, 51(5): 128-133.

ZHU Zhiping, YANG Lei, QIAO Yue, CAO Jie, ZHAO Yongfu. Experimental Study on Gas-Liquid Partition Coefficient and Thermal Decomposition Characteristics of Ethanolamine in High-Temperature Aqueous Systems[J]. Electric Power, 2018, 51(5): 128-133.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.201708272

https://www.electricpower.com.cn/CN/Y2018/V51/I5/128

参考文献

[1] 朱志平. 压水堆核电站水化学工况及优化[M]. 北京:原子能出版社, 2010.
[2] ODAR S, NORDMANN F. PWR and VVER secondary system water chemistry[C]//Advanced Nuclear Technology International Europe AB, A N T International. 2016.
[3] MILLETT P J, FRUZZETT K F. Status of application of amines in US PWRs[J]. Power Plant Chemistry, 2005, 7(10), 599-603.
[4] 沈君. 压水堆核电站二回路ETA水化学处理研究[J]. 核动力工程, 2014(6):122-125.SHEN J. Research of ETA water chemistry treatment technology in secondary circuit of PWR plant[J]. Nuclear Power Engineering, 2014(6):122-125.
[5] 孙昕. 中国电力建设技术进展及发展趋势-(下)电源部分[J]. 中国电力, 2017, 50(4):1-5.SUN Xin. Progress and development trend of electric power construction technology in China part Ⅱ-power source[J]. Electric Power, 2017, 50(4):1-5.
[6] 郑宽, 王轶禹, 王耀华, 等. "十三五"期间核电参与电网调峰前景分析[J]. 中国电力, 2017, 50(1):49-55.ZHENG Kuan, WANG Yiyu, WANG Yaohua, et al. Analysis on the load following prospect of nuclear power in China in the period of "13th Five-Year"[J]. Electric Power, 2017, 50(1):49-55.
[7] 徐玉明. 核电发展与核电材料的腐蚀防护[J]. 腐蚀与防护, 2016, 37(07):523-526.XU Yuming. Nuclear power development and corrosion protection of relevant materials[J]. Corrosion & Protection, 2016, 37(7):523-526.
[8] COBBLE J W, TUMER P J. Additives for pH control[R]. Palo Alto:EPRI, NP-4209, 1985.
[9] MILLETT P. PWR advanced amine application guidelines revision 2[R]. Palo Alto:EPRI, TR-102952-R2, 1997.
[10] 曹松彦, 孙本达, 黄万启, 等. 乙醇胺的热稳定性试验及其在核电站二回路系统的应用[J]. 腐蚀与防护, 2012, 33(11):1019-1021.CAO Songyan, SUN Benda, HUANG Wanqi, et. al. Experiment on thermal decomposition characteristics of ETA and its application to secondary system of NPP[J]. Corrosion & Protection. 2012, 33(11):1019-1021.
[11] 中国核动力研究设计院. ETA(乙醇胺)在二回路系统应用可行性研究(材料相容性部分)报告[R]. 成都, 2006.
[12] 赵永福, 王今芳, 马韦刚, 等. 核电站二回路乙醇胺的应用性能研究[J]. 核动力工程, 2014(6):167-171.ZHAO Yongfu, WANG Jinfang, MA Weigang, et al. Research on application characteristics of ethanolamine used in secondary system of nuclear power plants[J]. Nuclear Power Engineering, 2014(6):167-171.
[13] PARK K K, LEE J B. ETA chemistry experience and assessment on CPP in Korea[R]. Palo Alto:EPRI, INIS-FR-1613, 2002.
[14] MATHEWS J A. Organics in the power plant cycle - an EPRI perspective[J]. Power Plant Chemistry. 2008, 10(11), 650-656.
[15] RHEE I H, AHN H K, JUNG H J. Environmental regulation and removal of COD and N with the adoption of ETA in PWR[C]//9th WSEAS International Conference on Simulation, Modelling and Optimization. Budapest, 2009.
[16] 姜世楠. 乙醇胺CO₂吸收剂的理化性质[J]. 舰船防化, 2006, 2(2):19-23.JIANG Shinan. Physicochemical properties of monoethanolamine CO₂ absorbent[J]. Chemical Defence on Ships, 2006, 2(2), 19-23.
[17] 朱同清, 刘名玉, 郭振亮, 等. 艇用再生式CO₂吸收剂乙醇胺(MEA)使用寿命的研究[J]. 舰船科学技术, 1983, 12(1):29-36.
[18] 陶钧. ETA(乙醇胺)在秦山核电站二回路系统应用可行性研究(对凝结水精处理树脂运行影响部分)[D]. 上海:上海交通大学, 2005.

乙醇胺汽液分配系数及高温分解特性的试验研究

Experimental Study on Gas-Liquid Partition Coefficient and Thermal Decomposition Characteristics of Ethanolamine in High-Temperature Aqueous Systems

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

[1]	朱志平, 张俞, 石纯, 宋显志, 刘志峰. 核电站二回路碱化剂ETA的检测与干扰问题[J]. 中国电力, 2019, 52(8): 173-178,184.
[2]	赵永福, 姜峨, 龚宾, 温菊花, 唐敏, 银朝晖, 何艳春. 核电站二回路乙醇胺与氨复合应用可行性研究[J]. 中国电力, 2019, 52(4): 127-132.
[3]	汪建军, 李俊峰, 张守杰, 胡定科, 易强. 板框式旋转滤网清污性能分析及提升研究[J]. 中国电力, 2019, 52(2): 165-171.
[4]	张瑞祥, 高玉峰, 李康, 姚尧, 王震, 徐浩凇. 高温气冷堆二回路水汽品质优化方案探讨[J]. 中国电力, 2019, 52(1): 179-184.
[5]	周广吉, 徐岩, 张兰河. 红沿河核电站凝结水精处理系统的启动与运行[J]. 中国电力, 2017, 50(4): 123-129.
[6]	邓玲惠, 康豫军, 王军民, 程勇明, 王必宁. 冲击载荷作用下阀门阀瓣断裂失效的有限元分析[J]. 中国电力, 2017, 50(1): 125-129.
[7]	闫明晶, 翟巴菁, 代亚培. 压水堆核电站低压安注泵压降系数智能化计算的研究[J]. 中国电力, 2017, 50(1): 121-124.
[8]	刘宇穗. 核电站数字化控制系统驱动逻辑设计优化[J]. 中国电力, 2016, 49(6): 25-29.
[9]	毛雨佳，杨若冰，李京. 核电站重要厂用水系统两阶段关阀方案分析[J]. 中国电力, 2016, 49(5): 82-86.
[10]	冀润景，黄智星，石书雨. 百万千瓦核电站汽轮机旁排阀变更后的选型和验证[J]. 中国电力, 2016, 49(5): 76-81.
[11]	程学庆，闫培福，付银君，顾先青. AP1000核电站额定功率运行时单台给水泵跳闸瞬态分析[J]. 中国电力, 2015, 48(8): 121-125.
[12]	李建杰，孙洪波，刘佳，吕玉珍，王蔚. 纳米改性变压器油的热分解活化能研究[J]. 中国电力, 2015, 48(11): 67-70.
[13]	林良生，刘立，邹平国，陈红. 基于熵权的TOPSIS核一级锻件质量评价方法的探究[J]. 中国电力, 2015, 48(1): 56-59.
[14]	王保田. 某核电站一期工程循环水泵进水流道模型试验探讨[J]. 中国电力, 2014, 47(5): 113-117.
[15]	徐韧涛，孙世民，李振洲，孙放，彭跃. 台山核电站二期工程消防供水设施配置分析[J]. 中国电力, 2013, 46(5): 23-27.

模态框（Modal）标题

乙醇胺汽液分配系数及高温分解特性的试验研究

Experimental Study on Gas-Liquid Partition Coefficient and Thermal Decomposition Characteristics of Ethanolamine in High-Temperature Aqueous Systems

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics