超超临界锅炉水冷壁温度测试方法与应用研究

doi:10.11930/j.issn.1004-9649.201807038

中国电力 ›› 2019, Vol. 52 ›› Issue (1): 166-173.DOI: 10.11930/j.issn.1004-9649.201807038

超超临界锅炉水冷壁温度测试方法与应用研究

王洋^1,2, 汪华剑^1,2, 周虹光^1,2, 严响林^1,2, 白鹏^1,2, 卢琦^1,2

1. 西安热工研究院有限公司, 陕西西安 710054;
2. 西安西热锅炉环保工程有限公司, 陕西西安 710054

收稿日期:2018-07-12 修回日期:2018-09-09 出版日期:2019-01-05 发布日期:2019-01-14
作者简介:王洋(1988-),男,硕士,工程师,从事电站锅炉相关技术研究及应用工作,E-mail:741631415@qq.com

Study on Testing Method and Application of Water Wall Tube Temperature for Ultra-Supercritical Boiler

WANG Yang^1,2, WANG Huajian^1,2, ZHOU Hongguang^1,2, YAN Xianglin^1,2, BAI Peng^1,2, LU Qi^1,2

1. Xi'an Thermal Power Research Institute Co., Ltd., Xi'an 710054, China;
2. Xi'an TPRI Boiler & Environmental Protection Engineering Co., Ltd., Xi'an 710054, China

Received:2018-07-12 Revised:2018-09-09 Online:2019-01-05 Published:2019-01-14

摘要/Abstract

摘要： 锅炉水冷壁管温度的测试与控制是火电厂运行过程中的一个难题。通过在某台超超临界参数锅炉水冷壁管特定位置处安装能够同时测试水冷壁管向火侧壁温、背火侧壁温及管内工质温度的测试装置，实时监测水冷壁各工况下的管壁及工质温度变化，分析日常运行中各相关因素对水冷壁温度的影响特性。研究表明，启炉升负荷、变负荷工况吹灰以及水煤比失调等因素易导致或加剧水冷壁管壁温大幅突升，停炉过程和磨煤机投运方式的改变对水冷壁管壁温的影响较小。该测温装置及所得结论对火电厂水冷壁安全运行具有一定的指导作用。

关键词: 超超临界锅炉, 水冷壁管, 温度监测, 应用研究

Abstract: The measurement and control of water wall tube temperature has been a tough issue in thermal power plants. By virtue of some testing devices which are installed at special locations in the water wall tubes, the temperatures of fireside tube, backside tube and working medium inside the tube are measured and monitored on-line under various operating conditions for the analysis of the impacts of the relevant factors on the water wall temperature in daily operations. The study results show that the ramping up process after startup, the soot blowing during the load variation period and the water-coal ratio imbalance can cause or even aggravate the sharp rise of water wall tube temperature, while the ramping down process or the procedure change of coal mills do not affect much on the water wall tube temperature. The testing device and the study results can provide some guidance for the safe operation of the water wall in thermal power plants.

Key words: ultra-supercritical boiler, water wall tube, temperature monitoring, application study

中图分类号:

TK223.3

王洋, 汪华剑, 周虹光, 严响林, 白鹏, 卢琦. 超超临界锅炉水冷壁温度测试方法与应用研究[J]. 中国电力, 2019, 52(1): 166-173.

WANG Yang, WANG Huajian, ZHOU Hongguang, YAN Xianglin, BAI Peng, LU Qi. Study on Testing Method and Application of Water Wall Tube Temperature for Ultra-Supercritical Boiler[J]. Electric Power, 2019, 52(1): 166-173.

导出引用管理器 EndNote|Ris|BibTeX

链接本文: https://www.electricpower.com.cn/CN/10.11930/j.issn.1004-9649.201807038

https://www.electricpower.com.cn/CN/Y2019/V52/I1/166

参考文献 20

[1]	NICOL K. Status of advanced ultra-supercritical pulverized coal technology[R]. London:IEA Clean Coal Center, 2013.
[2]	张志正, 孙保民, 郭永红, 等. 超(超)临界压力锅炉膜式水冷壁危险点壁温在线监测方法研究[J]. 中国电机工程学报, 2005, 25(3):130-134 ZHANG Zhizheng, SUN Baomin, GUO Yonghong, et al. Research on on-line temperature monitoring of severe point on membrane water wall of ultra-supercritical boiler[J]. Proceedings of the CSEE, 2005, 25(3):130-134
[3]	陈有福, 徐颂梅, 管诗骈, 等. 炉膛火焰中心位置与下水冷壁出口壁温关系研究[J]. 热力发电, 2018, 47(6):71-77 CHEN Youfu, XU Songmei, GUAN Shipian, et al. Study on the relationship between the central position of furnace flame and the temperature of water wall outlet[J]. Thermal Power Generation, 2018, 47(6):71-77
[4]	王为术, 徐维晖, 李帅帅, 等. 1000 MW超超临界锅炉高热负荷区垂直水冷壁温度特性研究[J]. 电站系统工程, 2011, 27(6):9-12 WANG Weishu, XU Weihui, LI Shuaishuai, et al. Temperature study on vertical membrane water-wall of 1000 MW ultra-supercritical pressure boilers in high heat flux area[J]. Power System Engineering, 2011, 27(6):9-12
[5]	李斌, 汪华剑, 梁学东, 等. 超超临界锅炉水冷壁管传热恶化对横向裂纹影响的有限元分析[J]. 中国电力, 2015, 48(12):64-69 LI Bin, WANG Huajian, LIANG Xuedong, et al. FEM analysis of heat transfer crisis of water wall tube on transverse crack in ultra-supercritical pressure boiler[J]. Electric Power, 2015, 48(12):64-69
[6]	左帅, 张峰, 周波. 1000 MW超超临界锅炉机组冷态启动时水冷壁超温的探讨[J]. 中国电力, 2011, 44(5):60-64 ZUO Shuai, ZHANG Feng, ZHOU Bo. Over-temperature problem of water wall in 1000 MW ultra-supercritical boiler during cold start-up[J]. Electric Power, 2011, 44(5):60-64
[7]	许尧.1000 MW超超临界锅炉低氮燃烧改造后水冷壁腐蚀及其防治的研究[D]. 南京:东南大学, 2017.
[8]	汪华剑, 王洋. 锅炉燃烧器区域水冷壁管裂纹产生机理及研究(锅炉部分)[R]. 西安:西安热工研究院有限公司, 2016.
[9]	马巧春. 超超临界锅炉水冷壁壁温异常原因分析[J]. 中国电力, 2007, 40(7):21-24 MA Qiaochun. Reason analysis on the abnormal metal temperature on water wall tube of ultra-supercritical boiler[J]. Electric Power, 2007, 40(7):21-24
[10]	王为术. 超(超)临界锅炉内螺纹水冷壁管流动传热与水动力特性[M]. 北京:中国电力出版社, 2012.
[11]	滕叶, 张忠孝, 朱明, 等. 1000 MW超超临界锅炉水冷壁壁温计算[J]. 能源研究与信息, 2014, 30(4):209-213, 223 TENG Ye, ZHANG Zhongxiao, ZHU Ming, et al. Calculation on water temperature in a 1000 MW USC boiler[J]. Energy Research and Information, 2014, 30(4):209-213, 223
[12]	张世宏, 刘正强, 聂鑫, 等. 超超临界1000 MW机组锅炉水冷壁壁温偏差计算分析及对策[J]. 热力发电, 2017, 46(11):44-49 ZHANG Shihong, LIU Zhengqiang, NIE Xin, et al. Water wall temperature deviation of an ultra-supercritical 1000 MW unit boiler analysis and countermeasures[J]. Thermal Power Generation, 2017, 46(11):44-49
[13]	商显耀, 张忠孝, 董建聪, 等. 大容量超超临界锅炉水冷壁壁温特性研究[J]. 锅炉技术, 2016, 47(1):45-49 SHANG Xianyao, ZHANG Zhongxiao, DONG Jiancong, et al. Study on temperature characteristics of water wall in large capacity ultra-supercritical boiler[J]. Boiler Technology, 2016, 47(1):45-49
[14]	葛学利, 张忠孝, 范浩杰, 等. 热偏差和流量偏差对1000 MW超超临界锅炉水冷壁壁温影响的研究[J]. 中国电机工程学报, 2018, 38(8):2348-2357 GE Xueli, ZHANG Zhongxiao, FAN Haojie, et al. Study on the effect of flame offset and flow deviation on wall water tube temperature of 1000 MW ultra-supercritical boiler[J]. Proceedings of the CSEE, 2018, 38(8):2348-2357
[15]	董卫江. 超超临界锅炉膜式水冷壁危险点壁温在线监测研究[D]. 北京:华北电力大学, 2005.
[16]	雷学丽. 超临界锅炉膜式水冷壁壁温监测研究[J]. 武汉理工大学学报, 2010, 32(23):76-80 LEI Xueli. Research on temperature monitoring of severe point of membrane water wall of supercritical boiler[J]. Journal of Wuhan University of Technology, 2010, 32(23):76-80
[17]	张志正. 超(超)临界锅炉水冷壁安全监测与鳍片尺寸设计研究[D]. 北京:华北电力大学, 2010.
[18]	张世平, 安连锁, 李庚生, 等. 基于声学测温的水冷壁局部超温监测研究[J]. 动力工程学报, 2012, 32(4):302-307 ZHANG Shiping, AN Liansuo, LI Gengsheng, et al. Local overheating monitoring of water walls based on acoustic pyrometry[J]. Journal of Chinese Society of Power Engineering, 2012, 32(4):302-307
[19]	曹海涛. 锅炉燃烧器区域水冷壁管裂纹产生机理及研究(材料部分)[R]. 西安:西安热工研究院有限公司, 2016.
[20]	汪华剑, 周虹光, 王洋, 等. 1000 MW垂直管圈超超临界锅炉水冷壁工质相变转换对金属壁温影响的试验研究[J]. 锅炉技术, 2017, 48(6):13-18 WANG Huajian, ZHOU Hongguang, WANG Yang, et al. Experimental study on influence of working medium phase change on metal temperature of water wall tube in a 1000 MW ultra supercritical vertical water wall boiler[J]. Boiler Technology, 2017, 48(6):13-18

超超临界锅炉水冷壁温度测试方法与应用研究

Study on Testing Method and Application of Water Wall Tube Temperature for Ultra-Supercritical Boiler

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 7

编辑推荐

Metrics

[1]	石书雨, 李志, 赵超, 张勇, 杨天亮. 超超临界二次再热锅炉热力计算系统的研发及工程应用[J]. 中国电力, 2017, 50(2): 75-81.
[2]	郭杰，秦希超. 1 000 MW超超临界机组锅炉燃烧优化试验研究[J]. 中国电力, 2015, 48(5): 97-102.
[3]	李斌, 汪华剑, 梁学东, 王诚斌, 时标. 超超临界锅炉水冷壁管传热恶化对横向裂纹影响的有限元分析[J]. 中国电力, 2015, 48(12): 64-69.
[4]	许高俊, 马宏忠, 李超群, 李凯, 许洪华. 基于无线传感器网络的高压开关柜多点温度监测[J]. 中国电力, 2014, 47(12): 121-126.
[5]	邹磊, 岳峻峰, 陈永生, 梁绍华, 许亦然, 张恩先. 1 000 MW超超临界锅炉低NO_x燃烧技术改造及性能优化试验[J]. 中国电力, 2014, 47(10): 92-97.
[6]	孙伟鹏, 冯庭有, 庞力平, 曾壁群. 基于超超临界锅炉O₂/CO燃烧控制技术研究[J]. 中国电力, 2013, 46(7): 24-28.
[7]	吴劲松, 黄琦, 吴钟博, 陈辉煌. 光纤复合架空相线的工程应用研究[J]. 中国电力, 2013, 46(10): 106-110.

模态框（Modal）标题

超超临界锅炉水冷壁温度测试方法与应用研究

Study on Testing Method and Application of Water Wall Tube Temperature for Ultra-Supercritical Boiler

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 20

相关文章 7

编辑推荐

Metrics